Annual Check; Lifespan - Harken Industrial R27 Handbuch

LIFESPAN

WARNING!
At the end of the inspection, in case of identified faults, damaged parts, wear, corrosion,
deformation, faults that are detected during the compulsory periodical inspection, a fall with
consequent stress for the trolley has occurred, or doubts about the condition of the product,
DO NOT USE the trolley and contact an authorized Harken R27 Trolley Inspector or an
authorized Harken Service Center.
NOTE!
Check the legibility of the R27 trolley markings

Annual check

The frequency of periodic examination depends on the legislation, the equipment type, the frequency of use and
the environmental condition. The R27 trolley must be inspected thoroughly at least once every 12 months for
Personal Protective Equipment Regulation specification, or 6 months for Human Suspension.
WARNING!
The regular periodic examinations are needed procedures for the safety of users because the safety
of users depends upon the continued efficiency and durability of the equipment.
Contact an authorized Harken R27 Trolley Inspector for the mandatory inspection. The register of the authorized
Harken Industrial product inspector is available on the web site: http://www.harkenindustrial.com
Do not use the R27 trolley without performing the mandatory inspection. The inspection performed
by an authorized Harken R27 Trolley Inspector must be recorded in the Inspection/Repair Histroy Record of this
Manual and the Inspection report signed by the Inspector must be stored by the trolley owner.
It is recommended that the trolley is marked with the date of the next or last inspection.
WARNING!
DO NOT USE the R27 trolley if:
• you detect damage, wear, corrosion or deformation on the trolley
• faults are detected during the compulsory periodical inspection
• a fall with consequent stress for the trolley has occurred
LIFESPAN
The R27 trolley has a lifespan of 30 years from the manufacturing date, in the absence of causes which could
determine its decommissioning and on condition that all the periodic inspections required and any necessary
maintenance are carried out, with recording of their results on the Inspection/Repair history record.
The manufacturing date is indicated in the Serial Number of the trolley written in the trolley labelling.
16 ENGLISH 24/07/20