Use/Operating Personnel; Internded Use; Intended Use; Improper Use - BAHR ELZI 30 Montageanleitung

ELZI
30, 40, 60

5. Use/Operating Personnel

5.1 Intended Use

The positioning system may be used only for linear moving and positioning of workpieces, assemblies,
measuring devices or similar tasks of comparable nature in industrial plants.
The linear unit must not be used in explosive atmospheres or in direct contact with foodstuffs,
pharmaceutical or cosmetic products.
Catalogue information, the contents of these Installation Instructions and conditions stipulated in the order documents must
be observed. The load data indicated in these Installation Instructions are maximum values which must not be exceeded.
Overloads in any other areas must be avoided as well.

5.2 Improper Use

„Improper use" is any use not in compliance with the requirements mentionend in chapter 5.1 Intended Use.
In the event of improper use, inappropriate treatment or if this positioning system is used, installed or handled by unskilled
personnel, this linear unit may cause hazards for the staff.
If this positioning system is used improperly, Bahr Modulttechnik GmbH accepts no liability and the general operating permit
will become null and void.

5.2.1 Cases of Frequent Misuse

- Use in explosive atmospheres (if used in explosive areas, sparks can lead to deflagrations, fire or explosions)
- Use of the linear unit with tolerance exceeded
- Insufficient securing of the positioning system
- Insufficient securing of the loads to be moved
- Loads exceeding the indicated limits
- Use in the food industry with direct contact with unpacked foodstuffs
- Use outdoors
- Use in an environment with high humidity > dew point
- Use in heavily contaminated environments
- Use in extremely dusty atmospheres
- Use in atmospheres containing solvents
- Moving animals
- Use in liquids
- Use in temperatures below -10°C and above 60°C

5.3 Who may Use, Install and Operate this Linear Unit

Any authorized persons who have read and understood these Installation Instructions completely are allowed to use,
install and operate this positioning system. The responsibilities for handling this positioning system must be clearly
defined and adhered to.
Montageanleitung / Maschinenrichtlinie
Installation Instructions
24.09.2012
Seite / Page 10