Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC 1 .0 Wichtige Informationen KAPITEL 1 Zur Sicherstellung einer einwandfreien Funktion und zur eigenen Sicherheit sind alle nachstehenden Vorschriften genau durchzulesen und zu beachten. Dieses Dokument ist Teil des Produktes und als solches zugänglich und dauerhaft SICHERHEIT aufzubewahren.
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC • Gerät bis zum Einbau nur verpackt bewegen! • Gerät nur mit für das Gewicht geeigneten Transportmitteln bewegen. Beim Transport Sicherheitsschuhe tragen! • Beim Auspacken des Gerätes Handschuhe/Sicherheitsschuhe tragen. • Geeignete Tragkraft und Trageigenschaften des Befestigungsuntergrunds si- cherstellen und diesbezüglich geeignete Befestigungsmittel verwenden.
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC 1 .5 Berührungsschutz Beim Einbau sind die allgemein gültigen Arbeitsschutz- und Unfallverhütungsvorschriften einzuhalten! Der Betreiber ist für die Einhaltung verantwortlich! – Kontakt mit rotierenden Teilen muss verhindert werden. – In Abhängigkeit der Einbauverhältnisse kann ein Berührungsschutz erforderlich sein. Entsprechende Schutzgitter sind vorzusehen.
Garantieansprüche – Haftungsausschluss Alle Ausführungen dieser Dokumentation müssen beachtet werden, sonst entfällt die Gewährleistung. Gleiches gilt für Haftungsansprüche an Helios. Der Gebrauch von Zubehörteilen, die nicht von Helios empfohlen oder angeboten ALLGEMEINE HINWEISE werden, ist nicht zulässig. Eventuell auftretende Schäden unterliegen nicht der Gewährleistung. Veränderungen und Umbauten am Gerät sind nicht zulässig und führen zum Verlust der Konformität, jegliche Gewährleistung und Haftung...
* (Leistungs- u. Geräuschangaben aus den Der Schalldruckpegel kann im Einbaufall erheblich von der Katalogangabe abweichen, da er stark von den aktuell gültigen Helios Druckschriften und dem Internet) Einbaugegebenheiten, d.h. vom Absorptionsvermögen des Raumes, der Raumgröße u.a. Faktoren abhängig ist.
Seite 8
ALB EC 50/30 WW ø8 Alle Maße in mm 57,5 57,5 ALB EC 60/35 WW 57,5 ø8 57,5 Alle Maße in mm 57,5 57,5 57,5 57,5...
4 .0 Funktionsbeschreibung Die Außenluft-Box ALB EC sorgt für ein angenehmes Raumklima durch Zuführung externer Außenluft, die gefiltert und auf die vorgegebene Temperatur erwärmt wird. Das Gerät ist ideal für alle Räume geeignet, in denen saubere und vorgewärmte Frischluft benötigt wird. 4 .1 Übersicht Bedienteil Startbildschirm...
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC – Übersicht Anzeige aller Temperaturfühler, Ventilatorleistung und Leistung der Vorheizung. Info-Button ò: Anzeige von Geräte- und Schnittstelleninformationen. ò – Einstellungen Zeit und Datum Datum und Uhrzeit einstellen. Displayhelligkeit Helligkeit des Displays einstellen. Sprache Menüsprache auswählen.
Seite 11
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC Geschwindigkeit in Betrieb. In dieser Zeit wird der Messwert vom Luftqualitätssensor ignoriert. Anschließend kehrt das Gerät in den automatischen sensorgesteuerten Betrieb zurück. 09- Temperatursensor Auswahl des Temperatursensors, der für die Regelung entsprechend der Solltemperatur führend ist: Zuluftkanal- oder Raum-Temperatursensor.
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC 5 .0 Benutzerwartung KAPITEL 5 Es ist keine Benutzerwartung vorgesehen. BENUTZERWARTUNG Alle anfallenden Wartungsarbeiten sowie die Reinigung dürfen nur durch eine Elektrofachkraft erfolgen . ACHTUNG Alle nachfolgenden Informationen und Anweisungen sind nur für eine autorisierte Elektrofachkraft bestimmt! KAPITEL 6 6 .0...
– Ein allpoliger Netztrennschalter/Revisionsschalter mit mindestens 3 mm Kontaktöffnung (DIN EN 60335-1) ist bereits montiert. – Bei ALB EC 30/20 EH muss ein zusätzlicher Netztrennschalter/Revisionsschalter mit mindestens 3 mm Kontaktöffnung (DIN EN 60335-1) vor der Vorheizung vorzusehen! – Netzform, Spannung und Frequenz müssen mit den Angaben des Typenschilds übereinstimmen.
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC Leitung nie über scharfe Kanten führen! ACHTUNG Drehrichtung des angeschlossenen Ventilators überprüfen! Gerät gemäß Anschlussplan anschließen. 6 .3 Anschluss Warmwasser-Heizregister (ALB EC WW) Die Montage darf nur von einer Fachfirma durchgeführt werden, die gleichzeitig die Druckprobe der ACHTUNG Verbindung durchführt .
– Durchströmungsbereich, Laufrad, Verstrebung und Motor des Ventilators säubern. – Keine aggressiven, lacklösenden Mittel verwenden! – Hochdruckreiniger oder Strahlwasser sind nicht gestattet! 7 .3 Ersatzteile Es sind ausschließlich Helios Originalersatzteile zu verwenden. Alle Reparaturen dürfen nur von autorisiertem/en Fachpersonal/-Betrieben durchgeführt werden. 7 .4 Stilllegen und Entsorgen WARNUNG! WARNUNG Bei der Demontage werden spannungsführende Teile freigelegt, die bei Berührung zu einem elektrischen...
Montage- und Betriebsvorschrift Außenluft-Boxen – ALB EC Die allgemein gültigen Arbeitsschutz- und Unfallverhütungsvorschriften sind einzuhalten! – Elektroarbeiten dürfen nur von einer autorisierten Elektrofachkraft durchgeführt werden. – Geeignete Hebewerkzeuge und Befestigungsvorrichtungen zum Demontieren des Ventilators verwenden, Transportskizze beachten! – Die Komponenten entsprechend den gültigen Vorschriften und Gesetzen entsorgen. 7 .5 Fehlerbeschreibung Fehler...
Installation and Operating Instructions Fresh Air Boxes – ALB EC 1 .0 Important information CHAPTER 1 In order to ensure complete and effective operation and for your own safety, all of the following instructions should be read carefully and observed. This document should be regarded as part of the product and as such should be kept SAFETY accessible and durable.
Installation and Operating Instructions Fresh Air Boxes – ALB EC • Only transport fans using means of transport that are appropriate for the weight, wear protective gloves during transport! • Wear protective gloves/footwear when unpacking the unit. • Ensure the suitable load capacity and properties of the mounting surface and use suitable mounting material.
Installation and Operating Instructions Fresh Air Boxes – ALB EC 1 .5 Protection against contact The generally applicable safety at work and accident prevention regulations must be observed for installation! The operator is responsible for observing these regulations! – Contact with rotating parts must be avoided. –...
All versions of this documentation must be observed, otherwise the warranty shall cease to apply. The same applies to liability claims against Helios. The use of accessory parts, which are not recommended or offered by Helios, is not GENERAL INFORMATION permitted.
4 m) apply to free field conditions. With regard to installation, the sound pressure level can differ significantly from the * (performance and noise data from the catalogue data, as it is highly dependent on the installation conditions, i.e. on the absorption capability of the room, the currently applicable Helios documentation and the internet) room size among other factors.
Seite 30
ALB EC 50/30 WW ø8 All dim. in mm 57,5 57,5 ALB EC 60/35 WW 57,5 ø8 57,5 All dim. in mm 57,5 57,5 57,5 57,5...
4 .0 Functional description The fresh air box ALB EC provide a pleasant room climate by supplying external fresh air, which is filtered and heated to a specified temperature. The unit is ideally suitable for all rooms, in which clean and heated fresh air is required. 4 .1 Controller overview Start screen...
Seite 32
Installation and Operating Instructions Fresh Air Boxes – ALB EC – Overview Displays all temperature sensors, fan power and pre-heater power. Info button ò: Displays unit and interface information. ò – Settings Time and date Set date and time. Display brightness Set brightness of the display.
Seite 33
Installation and Operating Instructions Fresh Air Boxes – ALB EC sensor-controlled operation. 09- Temperature sensor Select the temperature sensor with priority for control corresponding to the set temperature: Supply air duct or room temperature sensor. Room temperature sensor optional, Connection to circuit board A1 terminal 55-56. 10- Supply air duct limit values Set the temperature limit values for the supply air (when using a room temperature sensor).
Installation and Operating Instructions Fresh Air Boxes – ALB EC 5 .0 User maintenance CHAPTER 5 There is no user maintenance. USER MAINTENANCE All necessary maintenance work and cleaning should only be carried out by a qualified electrician . ATTENTION All of the following information and instructions are only intended for an authorised qualified electrician! CHAPTER 6...
– An all-pole mains switch / isolator, with at least a 3 mm contact opening (DIN EN 60335-1) is already mounted. – With regard to ALB EC 30/20 EH, an additional mains switch / isolator, with at least a 3 mm contact opening (DIN EN 60335-1) must be mounted before the pre-heater! –...
Installation and Operating Instructions Fresh Air Boxes – ALB EC Connect unit in accordance with wiring diagram. 6 .3 Connection of warm water heater battery (ALB EC WW) The installation must be carried out by a professional company, which will also perform a pressure test on the ATTENTION connection .
– High pressure cleaners or water jets are not permitted! 7 .3 Spare parts Only original Helios spare parts are to be used. All repairs may only be carried out by authorised specialist personnel/ companies. 7 .4 Standstill and disposal...
Installation and Operating Instructions Fresh Air Boxes – ALB EC The generally applicable safety at work and accident prevention regulations must be observed! – Electrical work must only be carried out by an authorised electrician. – Use appropriate lifting equipment and fastening devices to dismantle the fan, Observe transport sketch! –...
Seite 40
Installation and Operating Instructions Fresh Air Boxes – ALB EC Wiring diagram SS-1301 ALB EC 30/20 EH I-BUS OUTPUT I-BUS INPUT I-BUS I-BUS I-BUS PE DC12V 57 58 59 60 61 62...
Seite 41
Installation and Operating Instructions Fresh Air Boxes – ALB EC Wiring diagram SS-1244 ALB EC 40/20 WW...
Seite 42
Installation and Operating Instructions Fresh Air Boxes – ALB EC Wiring diagram SS-1246 ALB EC 50/30 WW...
Seite 43
Installation and Operating Instructions Fresh Air Boxes – ALB EC Wiring diagram SS-1248 ALB EC 60/35 WW...
Seite 44
Installation and Operating Instructions Fresh Air Boxes – ALB EC Wiring diagram SS-1250 ALB EC 80/50 WW...
Seite 45
Installation and Operating Instructions Fresh Air Boxes – ALB EC...
Seite 46
Installation and Operating Instructions Fresh Air Boxes – ALB EC...
Seite 47
Installation and Operating Instructions Fresh Air Boxes – ALB EC...
Seite 48
HELIOS Ventilatoren GmbH + Co KG · Lupfenstraße 8 · 78056 VS-Schwenningen HELIOS Ventilateurs · Le Carré des Aviateurs · 157 av. Charles Floquet · 93155 Le Blanc Mesnil Cedex CH HELIOS Ventilatoren AG · Tannstrasse 4 · 8112 Otelfingen GB HELIOS Ventilation Systems Ltd.