Security Tips; Servicing - profi-pumpe DIESEL DPY01114-4 Bedienungsanleitung

03 English

5. SECURITY TIPS

l Do not leave the motor running, when not in operation.
l Clean the fuel strainer regularly.
l Obey absolutely valid regulations on the electrical security
l When operating suitable protective gloves must be worn.
l Never run pump dry
l Never run pump against pressure
l Pumping inflammable, as well as all other aggressive liquids, except of diesel or fuel oil, is prohibited
l Never pump liquid food products
l Before usage, check on the tightness of the hose clamps
l Pay attention to the max. liquid temperature of 35°C
l Never pull the pump on the electrical cable or pressure hose
l Disconnect the plug immediately from the power grid when the line has been damaged or severed
l Switch off pump immediately after usage
l Don't move the pump in any way, while it's running
l During longer unused times, clean the pump, wash it out with diesel or fuel oil, dry and store it at room
temperature
l ALWAYS supervise and watch the pump, while using
l The electrical connections are always to be carried out by an authorised professional
l Operation can not be performed by children and young people under 16 and people with intellectual disabilities
l The pump must be protected from rain and moisture. The pump may only be operated in dry rooms. The
ingress of water into the energized components of the pump increases the risk of electric shock
l If you do not intend to use the pump for an extended period of time, drain the fluid from the the pump,
flush it out with diesel/heating oil and store it dry at room temperature
l Pumping of liquids other than diesel or fuel oil is prohibited
l If you do not intend to use the pump for an extended period of time, drain the fluid from the the pump,
flush it out with AdBlue ® * and store it dry at room temperature
l Pumping of liquids other than AdBlue ® * is prohibited
AdBlue ® * can not be mixed with diesel,
because the chemical is injected from a
separate tank into the exhaust system.
Where ammonia is released, which
reacts with the nitrogen oxides in the
catalyst and converts to nitrogen and
water vapor
AdBlue ® * consists of 32.5% urea and
67.5 of demineralized water.
AdBlue ® * is odorless and non-toxic, not
flammable, explosive or dangerous for
the environment.
THE MANUFACTURER EXPLAINS:
l To take over no responsibility in the case of accidents or damages on the basis of carelessness or disregard to the
instructions in this user manual.
l To reject every responsibility for the damages which originate from the improper use of the pump

6. SERVICING

Under normal pumping conditions the pump requires no servicing.
But it is important to keep the suctions and delivery sections perfectly clean and free from all clogging.
The following controls should be carried out regularly:
l Intactness of the electric cable
l That the connection hoses are not bent or broken
l Cleanness of the pump medium
Moreover, the pump should be emptied at risk of frost, be washed out with diesel/fuel oil and stored dry.
ATTENTION!
DIESEL
DO NOT MIX!
AdBlue
®
AdBlue DIESEL
®