Maintenance / Cleaning - Oase AquaMAX 3500 Gebrauchsanweisung

Important note:
-
-
Additional Installation instructions:
Our specified outputs are always measured directly at the pump outlet (without
hose connection and accessories).
To achieve the highest possible pump output, keep the hose connections as short
as possible. Elbows, angles and other connecting elements should be reduced to
a minimum, as they lessen the pump output.
6.0 Maintenance/cleaning
-
-
-
6.1 Dismantling (see figure. page 12)
-
-
-
-
-
-
6.2 Cleaning the pump
-
-
-
Warning: Never open the motor housing. Life threatening hazard!
6.3 Assembly (see figure. page 12)
-
-
-
7.0 Winter care
-
-
-
-
-
10
Aquamax 3500 Export NEU.p65
GB Operating instructions Operating instructions
Never operate the pump without the filter basket. The filter basket protects
the pump from coarse dirt that can lead to plugging up the pump.
Never operate the pump without water (dry run). The pump bearings will be
destroyed!
Follow the safety instructions (section 4.0).
Clean the filter housing monthly, or if the pump capacity is reduced, by
using a soft brush under running water or use the OASE special cleaner
(order number 52969).
Also clean the pump in the case of frequent use (for dismantling see section 6.1)
Remove screw.
Pull out holding projection.
Depress locking button.
Remove filter housing (1).
Remove the pump from the filter housing (2).
If required, loosen the cap nut (9) between pump housing (6) and
swivel joint (7).
Dismantle the filter housing (section 6.1)
Clean the pump with a soft brush under flowing water.
Remove any grime in the rotor through the openings.
Lay the pump in the lower part of the filter housing (2).
Place cable in the cable guide (for Aquamax 15000 the cable should have
been previously placed in a runner).
Further assembly is the reverse sequence of the steps described
in section 6.1.
Take the pump out of the water.
Thoroughly clean the pump (see section 6.0)
Check the pump for damage.
Store the pump in frost-free conditions, in a container with water if possible.
Caution: Never immerse the connecting plug!
10
GB
14.02.2003, 10:50