Troubleshooting - SXT-Scooters Gekko 1200 Handbuch

Problem
When I turn my
Vehicle on nothing
happens.
The range is low
The Throttle does not
work or switch on,
the vehicle moves
without acceleration.
The breaks are not
working properly

TROUBLESHOOTING

TROUBLESHOOTING
Condition
1. No any light
Indications on the
display.
2.Power indication
light is on
3. Power indication
light is on and the
break light is "on".
1. The Throttle does
not return to stop
position.
Charger light is off
Battery doesn't hold
the charge
1. Break levers go
too deep
2. No breaking
power
23
Check
1. Check the main
Breaker under the
seat if it is on "ON"
position.
2. Check power
Connection and
battery level.
3.Check battery and
motor connection
4. Check the break
Levers if they return
to normal position.
5. Battery voltage is
below 56 volts.
1. Check the grip for
damage
2. Check the Throttle
spring.
3.The Throttle handle
if it is loose
1.Bad connection
between the charger
and the battery.
2.Charger doesn't
charge
1. Connections
between the batteries
are not good.
2. Bad battery cell
1.Needs adjustment
2. Break pads are
dirty or need repla-
cement.
9 3
SXT-SCOOTERS
Solution
1. Flip the breaker
lever on "ON"
2. Fasten connections.
3. Clean and fasten
battery terminal
connectors.
4. Fasten the motor
connections With the
controller under seat
5. Loosen the break.
If there is any corro-
sion replace. Contact
the supplier.
6. Charge or replace
battery. Contact the
supplier.
1. Use a flat head
screwdriver to adjust
the gap between the
rubber handle and
the cover.
2.Readjust the Thrott-
le spring position.
Contact the supplier
3.Check Throttle
connections. Contact
the supplier.
1.Check the charger
plug position.
2. Replace the
charger
1.Check all connec-
tions between the
batteries
2. Replace the bad
battery cell.
1. Adjust the break
cable – see instruc-
tions.
2. Clean break pads
using sand paper or
replace.