Die Einbauzeit beträgt ca. 48 AW, die je nach Zustand und Ausstattung des Fahrzeugs abweichen kann. Montageanleitung Nr.: 1100 286 710 / Stand: 13.04.2016 / TSch / REV01 Fax –135 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130...
Seite 3
Die Einfahrhinweise für Motor und Hinterachsgetriebe des Fahrzeugherstellers sind zu beachten. Montageanleitung Nr.: 1100 286 710 / Stand: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 9
Stromlaufpläne zur Kontrolle tagesaktuell aus dem BMW ISTA System zu entnehmen. Montageanleitung Nr.: 1100 286 710 / Stand: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 10
Lötverbinder und Kabelbaum isolieren und AC Schnitzer CAN_Bus Stecker mit dem AC Schnitzer Kabelbaum verbinden. Achtung! Auf richtige Signalzuordnung achten! Montageanleitung Nr.: 1100 286 710 / Stand: 13.04.2016 / TSch / REV01 Fax –135 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130...
Seite 11
Öffnung, nach vorne verlegen und mit den mit- gelieferten Kabelbindern befestigen. Montageanleitung Nr.: 1100 286 710 / Stand: 13.04.2016 / TSch / REV01 Fax –135 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130...
Seite 12
Das Echtheitszertifikat wird dem Besitzer bei Fahrzeugübergabe ausgehändigt ! Montageanleitung Nr.: 1100 286 710 / Stand: 13.04.2016 / TSch / REV01 Fax –135 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130...
Seite 16
Carry out all work in accordance with applicable safety regulations. The AC Schnitzer performance upgrade is fitted with a Plug & Play wiring harness and must be installed in the vehicle as described in these Fitting Instructions. The guarantee applies only in the case of correct installation. Disconnect the vehicle battery before installing the AC Schnitzer Performance Upgrade.
Seite 17
The manufacturer's instructions for running in the engine and final drive gear must be observed. Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Boost pressure sensors ahead throttle valve right & left Rail pressure sensors right & left Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 20
Release the cowl fixing bolts (5 x) and remove cowl upwards. Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 21
Fig. 6 & 7 Boost pressure sensors right and left. Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 22
If necessary, use supplied rail pressure adapter 1214 10 880. Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 23
BMW ISTA system for checking. Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 24
Expose the wiring harness plug to around 5cm from the plug. Cut around 5cm from the plug the red and blue CAN_bus lines. Solder the cable ends of the AC Schnitzer CAN_bus plug and the CAN_bus cable ends of the vehicle wiring harness together using the solder connectors supplied.
Seite 26
The authenticity certificate is given to the vehicle owner on handover! Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...
Seite 27
Subject to errors, modifications and technical development! * country-specific Fitting Instructions No.: 1100 286 710 / Issue: 13.04.2016 / TSch / REV01 AC Schnitzer - automobile Technik - Neuenhofstraße 160 - D - 52078 Aachen - Tel. 0241/5688 -130 Fax -135...