Taking Care Of Unexpected Problems - CGM DUAL15000SP Benutzerhandbuch

TAKING CARE OF UNEXPECTED PROBLEMS

Engine Will Not Start
1. Check control positions
2. Check fuel
3. Check engine oil level.
4. Remove and inspect spark
plug.
5. Take generator to an
authorized THIS servicing
dealer or refer to shop
manual.
Engine Lacks Power
1. Check air filter.
2. Check fuel.
3. Take generator to an
authorized THIS servicing
dealer or refer to shop
manual.
Possible Cause
Fuel valve lever OFF.
Choke OPEN.
Engine switch OFF.
Out of fuel.
Bad fuel: generator stored without treating or
draining gasoline or refueled with bad
gasoline.
Low oil level caused Oil Alert to stop engine.
Spark plug faulty, fouled, or improperly
gapped.
Spark plug wet with fuel (flooded engine).
Fuel filter restricted, carburetor malfunction,
ignition malfunction, valves stuck etc.
Possible cause
Air filter restricted.
Bad fuel; generator stored without treating or
draining gasoline, or refueled with bad
gasoline.
Fuel filter restricted, carburetor malfunction,
ignition malfunction, valves stuck etc.
Correction
Turn lever ON.
Move to CLOSED
Turn engine switch to ON.
Refuel (p.18).
Drain fuel tank and carburetor (p.27).
Refuel with fresh gasoline (p.18).
Add oil (p.20). Turn engine switch to OFF
and restart the engine.
Gap, or replace spark plug (p.23).
Dry and reinstall sparkplug.
Replace or repair faulty components as
necessary.
Correction
Clean or replace air filter (p.22)
Drain fuel tank and carburetor (p.27).
Refuel with fresh gasoline (p.18)
Replace or repair faulty components as
necessary.
66