Schaltplan (Rev Kopf) - 56601806 Bearbeitung A Blatt 1 Von 2 - Nilfisk-Advance 2800ST Wartungshandbuch

Schaltplan (REV Kopf) - 56601806 Bearbeitung A Blatt 1 von 2

CB1
RED 2 1
CIRCUIT BREAKER, 70A.
~
CIRCUIT BREAKER, 10 AMP KEY SWITCH
CB2 SW2
2
RED 2 1 BRN/GRN 1
BRN/GRN
K1
3 4
CONTACTOR VACUUM
K2
3 4
CONTACTOR BRUSH
L1
1 2
SOLUTION SOLENOID VALVE
B+
NOTES:
1. REFERENCE WIRING DIAGRAM 56601807
2. DISCONNECT RED WIRE ON CB2 AND REPLACE WITH
GREEN WIRE FROM CHARGER WHEN CHARGER IS USED.
3. WHEN VIEWING FROM THE TOP RIGHT BOOST MOTOR TURNS
COUNTER CLOCKWISE, LEFT BOOST MOTOR
TURNS COLCKWISE
78 - FORM.NR. 56043121 - Advenger / 2800ST, 3400ST / BR 755, BR 855
FORMS.DSN - C SIZE FORM 1/12/99
F1
RED 1 2 RED
FUSE, 150A.
RED
E2
B+ B-
CHARGER DELTA Q
GND
WHT/BRN
2
EMERGENCY SWITCH
SW3 SEAT SWITCH
2 BLK/ORN 1 2 WHT/BRN WHT/BRN
BRN/GRN SEAT
J3-1 B+
SWITCH J3-4
BRN/GRN
J3-8 B+
BLU/ORN
J3-14 KEY SWITCH
E3
MAIN MACHINE CONTROLLER
MOTION J3-6
J3-12 VACUUM
GRY/BLK
STATUS J3-7
CONTACTOR
REV. ALARM J3-5
SPEED LIMIT J2-4
WHT/RED
J3-13 BRUSH
CONTACTOR
POT. HIGH J2-6
POT. LOW J2-5
VIO/BLK
J3-11 SOLUTION SOLENOID
BATTERY PACK, 24 Vdc
BT1
+ -
BRN/BLK
BLK
LP1
1 2
FLASHING WARNING BEACON
OPTIONAL
SW1
1 2 BLK/GRA BLK/GRA
BLK/GRA ORN
Y1
ELECTRIC BRAKE
E1
WHEEL DRIVE
CONTROLLER
RED/WHT
PIN 6 - BRAKE -
ORN/BLU
PIN 9 - STATUS
BLU/BLK
PIN 16 - REV. ALARM
PIN 8 - MODE
BLK/WHT
PIN 18 - SPEED LIMIT
VIO
PIN 13 - POT. LOW
GRY
PIN 4 - POT. WIPER
YEL
B
YEL
VIO C A
PIN 3 - HIGH
DRIVE PEDAL SENSOR
SW4
NOTES UNLESS OTHERWISE
DRAWN
SPECIFIED
1. ALL DIMENSIONS IN INCHES. CHECKED
2. DO NOT SCALE DRAWING.
3. ALL DIMENSIONS APPLY AFTER PROJ ENG
PLATING AND HEAT TREATING,
BUT BEFORE PAINTING. APPROVED
4. REMOVE ALL BURRS AND SHARP
EDGES. APPROVED
DIM. IN [ ] ARE MM.
APPROVED
UNITS IN [ ] ARE ISO METRIC
AS NOTED.
FIRST USED ON
CONFIDENTIAL
THIS DRAWING AND THE DESIGN REPRESENTED HEREON IS THE PROPERTY OF NILFISK-ADVANCE, INC.,
PLYMOUTH, MINNESOTA AND IT HAS BEEN ISSUED WITH THE UNDERSTANDING THAT IT WILL NOT BE REPRO-
DUCED NOR COPIED NOR USED FOR ANY PURPOSE OTHER THAN FOR WHICH IT WAS ISSUED AND RECIPIENT
AGREES TO RETURN IT UPON REQUEST.
DWG. NO. 56601806 SHEET
1 OF 2
REV ECO
A-08516
A
BLK
BLK
BLK
B-
RED/GRN
M-
-
M
M1
+
YEL/BLK
M+
B-
8-8-12 PMO
NILFISK-ADVANCE, INC.
8-8-12 CK PLYMOUTH, MINNESOTA 55447-3408
TITLE
DIAGRAM-LADDER
SIZE DWG. NO.
C
56601806
ORCAD
REV 3 56601E53
SCALE ASSY.
REVISIONS
DATE DFTM APPD
9-27-12 PMO WGL
RELEASE
REV.
A
1 OF 2
SHEET