Service Instructions - Meister MOF1200-1 Originalbetriebsanleitung

• While routing: empty connected vacu­
um cleaner at regular intervals.
Blocked extractor ducts cause chips
to collect in the work zone!
Cleaning
Risk of injury! Always unplug
from mains before cleaning!
After finishing work
• Using a dry brush, clean dust and
chips from ventilation slots.
• Clean the outside of the housing with
a slightly moist cloth and allow it to
dry well.
Risk of damage to appliance! Do
not use liquids to clean router!
Do not use solvents!
Repair
Replace carbon brushes
If carbon brushes are worn, the motor will
run unevenly, stop or start sluggishly.
The carbon brushes must be replaced
by approved specialists only.
Fault tracing and repair
• Router will not start? Check supply
socket and associated mains fuses.
Ensure correct mains voltage (see
„Technical Data"). Or: Have carbon
brushes checked by approved spe­
cialists.
• The routed surfaces are rough or
uneven? The router head is blunt or
misaligned. Or: The feed rate is too
high. Or: The speed is too low.
MW-5458010-Bedien-2004.indd 69 MW-5458010-Bedien-2004.indd 69
• The routed surfaces are dark
coloured? The router head is over­
heating. Allow to cool down! Or: The
feed rate is too high. Or: The speed is
too high.
• The motor slows down considerably
during routing? The feed rate is too
high. Reduce feed rate!
• The motor runs irregularly, stops,
or starts with difficulty? Have the
carbon brushes exchanged by author­
ised specialists.
• The router gets very hot? Critical
continuous operation under full load.
Stop work and allow machine to cool
down!
CAUTION! Electrical and battery
operated units that no longer work
should not be disposed of in the house­
hold waste! They are to be collected
separately, in accordance with the
2012/19/EU directive for
the disposal of electrical
and electronic waste, and
sent for proper and
environ mentally­friendly
recycling.
Please discard power tools no longer
usable at a local collection point. Col­
lection and disposal of packaging
materials separately by types complying
with local rules and regulations. For
details, please contact your municipal
authority concerned.
11 – Service instructions
• Store the machine, operating instruc­
tions and where necessary the acces­
sories in the original packaging. In this
69
27.04.20 10:05 27.04.20 10:05