Zipper ZI-RPE60C Betriebsanleitung Seite 22

Use the machine only in good enough light to allow a safe operation can be

guaranteed.
In tiredness, decreased concentration or under the influence of alcohol or drugs,

the work on the machine is prohibited!
Caution in slippery conditions - slip hazard - risk of injury. When working, robust

and non-slip footwear. Slides / stumble / traps are a major cause of serious injury
or death.
The machine may only be operated by trained personnel.

Unauthorized persons, especially children and not trained personnel must be kept

away from the running machine!
If you pass the machine to third, these instructions must be attached to the

machine.
Before each use, the reliability of the machine is to be checked (the proper

function of the throttle lever)
During working with the machine near the border of quarries, caverns, acclivities

or embankments it is essential to make safe that the compactors
overbalance.
Danger of burns! During the operation flow of hot exhaust gases and engine parts

such as the muffler and engine become hot.
 After the operation, the machine must cool down. Otherwise there is an imminent
risk of burns
WARNING: Gasoline is highly flammable!

Smoking and open flames are prohibited during refuelling. Do not refuel when the

engine and carburettor are still very hot.
Refuel only outdoors or in a well ventilated area.

Avoid contact with skin and clothes (fire hazard).

Check after refuelling tank cap and check for leaks.

Start the engine at least 3 meters from the tank location.

Spilled fuel is wipe immediately.

Gasoline should be stored only in specially designated containers

If petrol has overflowed do not attempt to start. Instead the engine of the petrol

polluted area must be removed. Any attempt at ignition should be avoided until
the volatilization of the resulting gasoline vapors
Damaged fuel tank or other tank closures must be replaced

After the end of the operation close the fuel lever (if available)

Do not let the engine running in closed or not limited areas.

The exhaust contains poisonous carbon monoxide. The stress can lead to

unconsciousness and death.
 If the fuel tank has to be emptied, this must be done outdoors. Keep the drained
fuel in a specially designated container or dispose of carefully
 No other person shall remain within 15m, especially children and pets!
TRANSPORT NOTES:
Switch off the engine

Make sure that the lifting device is able to lift the machine sufficiently according

to the weight.
Fix the lifting hook at the marked point at the frame of the compactor (lifting

point) and lift the machine slowly to avoid injuries.
Pay attention that nobody is under suspended loads during the lift.

ZIPPER MASCHINEN GmbH www.Zipper-Maschinen.at
ZI-RPE60C – ZI-RPE90C22
 Use personal safety equipment: ear protectors, safety
goggles, safety shoes and working wear when working with
the machine
SAFETY
are not able to
22