General Aspects - HEYLO HWA 600 Bedienungsanleitung

(1) General aspects

CAUTION: Read carefully before starting up !
Please observe the notes in the operating instructions carefully. In case of non-observation of the user
manual, the warranty claims will become void. The manufacturer shall not be liable for any damage
and/or consequential damage resulting on the unit.
Introduction This chapter contains general information on the unit and manual.
Target group This manual is intended for technicians who install the unit, carry out maintenance
work and replace faulty parts.
Copyright The duplication of the this manual in whole or in part shall be permitted only upon
written approval of HEYLO GmbH.
Reservation HEYLO GmbH reserves the right carry out modifications and improvements on the
product and in the manual at any time without previous announcement.
Disposal The unit has been designed for many years of operation. If it has to be disposed of,
the competent legal regulations have to be observed in environmentally-gentle
manner.
Safety guidelines !
Keep away from children: Do not allow children to play with or in the vicinity of the unit.
Electric connection: The water separators have been designed for operation on 230 V / 50 Hz. Use
shockproof plugs only ! The sockets have to be earthed or protected by residual current circuit-
breakers with min. 30 mA.
Protect the power cable against damage: Never use the unit with damaged power cable. If the
power cable has been damaged, it has to be replaced by a cable of the same type and dimension.
Extension cable: Use approved extension cables only !
Handle with care: Do not drop or throw the unit as this may cause damage to the unit or wiring.
Operate on solid surface: Always set up the unit on a solid and plane surface.
Secure during transport: When transporting devices in vehicles, secure against slipping.
Keep dry: The unit must not be operated in puddles or in standing water. Do not store or operate
outdoors. If the electric wires or parts of the unit get wet, the unit has to be thoroughly dried before re-
using.
WARNING!
1) Suction side
HEYLO water separators (HWA) are operated with side channel blowers (SKV).
Compressors of the HEYLO series have a strong intake air. Small objects and particles might be
sucked in and thus damage the unit or cause injuries when being ejected. It has to be made sure that,
during operation of the compressor, nobody is in the vicinity of the suction opening or the exhaust
opening. If no pipe system or hose connection is connected on the intake or exhaust side, a protective
grid has to be attached. This is not installed as standard when compressors are delivered. It must be
ensured that no contaminants are sucked in the compressor or can get into the compressor during
standstill.
2) Exhaust side
Compressors of the HEYLO series have a high exhaust flow. Objects and particles sucked in can be
ejected at high speed and cause injuries. Therefore, never hold your hand in the exhaust opening.
3) Temperature at the turbine
During operation, the temperature of the conveying medium transfers to the turbine housing, with
temperatures exceeding 50°C only after a short time. Therefore, never touch the turbine housing
during operation and always let it cool off first.
11
EN