Commissioning - Jung JKB Serie Betriebsanleitung

4.4 Commissioning

DANGER
The total weight of the transport load and the position
of the centre of gravity must be known before the
lifting and moving operation. The weight of the
transport load must not be greater than the permitted
carrying capacity of the trolleys. Otherwise, tipping or
slipping can lead to injuries or even to fatal accidents.
Always determine the centre of gravity before using
JUNG trolleys.
For the determination of the centre of gravity, see
"Centre of gravity determination and positioning of
transport trolley and jack", page 39.
WARNING
Always place the trolleys on a flat, firm, non-slip sur-
face. Observe the point load and make sure the ground
is sufficiently stable.
WARNING
When using the trolley with a transport load, there
is a danger of crushing. Always wear safety clothing.
Otherwise, accidents and injuries could occur.
WARNING
If the height of the load exceeds the length of the
side to be lifted, appropriate safety precautions must
be taken in order to prevent the load from toppling
over. This applies in particular to machines in which
the centre of gravity is located in the upper half of
the load. Inform yourself about the dimensions of the
transport load and determine the centre of gravity in
order to avoid injuries.
- 46 -
JKB revolving transport trolleys / JLF multi-purpose trolleys
DANGER
Operating personnel has to ensure that other unin-
volved persons keep a safety distance of at least 1.5
times the height of the transport load on all sides of
the transport load. If there is a risk that uninvolved
persons could suddenly enter the danger area, the
danger area must be closed off appropriately. Failure to
do so can result in injury or even fatal accidents.
NOTE
For safe lifting, the use of hydraulic JUNG jacks is
recommended.
NOTE
Observe the operating instructions of the JUNG jacks.
DANGER
Be sure to use the connecting rod for the individual
trolleys. As a result, the trolleys are guided parallel to
the load if the floor is even, clean and without steps.
Otherwise, tipping or slipping can lead to injuries or
even to fatal accidents. Secure the transport load.
CAUTION
Be sure to observe the order of the work steps.
© JUNG Hebe- und Transporttechnik GmbH