Technical Data Of Bv-F01 Pedelec; Faults / Cause / Remedy - Lindsey-west bicycle BV-F01 Benutzerhandbuch

Technical data
of BV-F01 Pedelec
Drive system
Pedelec/EPAC (Electrical Power Assist Cycle)
Extra cycle drive with 250W motor, supports up
to 25 km/h, activated via Pedal rotary sensor.
Motor
BLDC gear - motor. The full form of BLDC is
Brushless-DC i.e., a brushless electronically
commuted 3-phase DC motor, works with max.
250W steady nominal power.
Control
BLDC motor controller with digital program
control according to Euro standard. 2 Drive
modes: normal and Eco. The auxiliary actuator
is automatically activated upon use of the pedal,
and assists travel at speeds of up to max. 25
km/h. If the brake is activated, the auxiliary
actuator is automatically shut o . In Eco mode,
the operating power level is restricted.
Battery
37V 8,8Ah (325Wh) Lithium-ion Battery of
European manufacture with 5 LED capacity
display, weight 2.4 kg, up to 500 full charging
cycles or 3 - 4 years life expectancy under
optimum use conditions.
Charging device
CC-CV charging device with 2.0A charging
current full charging of 37V 8,8Ah battery lasts
about 5 h. Another 2 hours of further charging
for optimized cell balancing is recommended
every tenth full charge.
Mileage
Depends significantly on the selected operation
mode, one's individual manner of driving - along
with other factors!
BV-F01 Pedelec

Faults / Cause / Remedy

1. Operating unit
1.1 No LED lights up at the left on activating the
Pedelec
Cause:
Battery is not inserted
properly
Fault in battery
Cable / contact fault
Electronic circuit is
defective
1.2 The Pedelec switches o during the drive
Cause:
Battery is empty
Electronic circuit
is defective
Plug-in connection
has disengaged
2. Battery
2.1 No LED lights up on pressing the battery
charging status display switch
Cause:
Battery is empty
Fuse in the battery
is defective
Cells in the battery pack
are defective
2.2 The capacity of the battery has come
down drastically
Cause:
The battery is
used-up (old)
The charging device
is defective
Charging plug / charging
cable is damaged
with Lithium-ion battery
Remedy:
> Re-insert battery
>Contact dealer
> Contact dealer
> Contact dealer
Remedy:
> Recharge battery
fully
> Contact dealer
> Contact dealer
Remedy:
> Charge the battery
fully.
> Replace fuse
> Contact dealer
Remedy:
> Replace the battery
> Contact dealer
> Contact dealer
45
GB