Deuba monzana DBES001 Bedienungsanleitung Seite 12

13.
work properly.
•
cable.
•
cable.
be connected backwards.
Correct any such issue before use.
14. Stay out of the direct line that the wire rope is
pulling. If it slips or breaks, it will "whiplash"
along this line. Place heavy rag or carpet
over wire rope span 6 feet from hook to help
absorb the force released if the wire rope
breaks. (See Figure E.)
Figure E: Whiplash Dampening Blanket or Rug
15. Do not maintain power to the winch if the
motor stalls. Verify load is within rated capacity
Use double line rigging whenever possible.
Double Line Rigging
a. A double line system should be used whenever
possible. It reduces the load on the winch,
allowing it to work longer with less heat
buildup. It reduces load on the winch in two
ways:
•
have higher capacity, and
• It halves the load on the winch through pulley
b. Connect the wire rope for a double line system
as shown in Figure F below. Use a pulley block
(sold separately) properly rated for the load to
be pulled and designed to be operated with
this winch's wire rope.
and leave in neutral)
Load
Carpet
Figure F: Double Line setup
c. Loop the wire rope around the pulley and
connect to another part of the vehicle's chassis
or to a separate anchor point. Do not anchor
the Wire Rope back to the winch or winch
mount.
Note: If anchoring the winching vehicle, only
rear of the vehicle, the vehicleʹs frame may be
damaged by the forces exerted by winching.
16.
17.
is safe to operate the winch. Make sure the
18. Do not use the hand crank, if equipped, to
"assist" the winch.
www.Deuba24online.de
19. Do not use vehicle to pull on the Wire Rope
and "assist" the winch.
20. Use as intended only.
purposes.
21. Prevent entanglement. Do not wear loose
clothing or jewelry, as they can be caught
in moving parts. Non-skid footwear is
to contain long hair.
22.
near the Wire Rope, drum, fairlead or load, to
23. Inspect before every use; do not use if
damaged or parts loose. Examine the winch
for structural cracks, bends, damage, frayed
winch. Do not use the winch even if minor
damage appears. A kink permanently weakens
out; kinked wire rope can fail suddenly and
must not be used.
24. Keep wire rope straight to avoid kinking the
kink forms and how to prevent kinking.
•
about to form. At this point
the winch should be stopped
and the wire rope should be
straightened out to prevent
kinking.
• This wire rope is kinked.
It is too late to reverse
the damage at this
point, the wire rope
must be discarded. It is
permanently damaged
and must not be used.
www.De uba24o nline. de
22 23
• This is a kinked
wire rope that has been straightened out.
Even though it has been pulled straight, some
wires in the wire rope are stretched, and
others are severely bent, if not broken. The
unstretched wires will take more load and can
• fail suddenly before the rope reaches its
capacity. This wire rope must be discarded
and not be used.
A kink permanently weakens the wire rope,
rope can fail suddenly and must not be used.
25. Keep children and bystanders away while
control.
26. Stay alert, watch what you are doing and
winches may result in serious personal injury.
27.
28. Hook onto the object using a pulling point,
tow strap or chain. Do not wrap the wire
rope around the object and hook onto the
wire rope itself. This can cause damage to the
object being pulled, and kink or fray the wire
rope.
29. Do not use a Recovery Strap while winching.
They are designed to stretch and can suddenly
whip back towards the operator during a
30.
NO LOCKING MECHANISM.