Inhaltsverzeichnis
Werbung
Montage- und Betriebsanleitung / Mounting and operating guide
EvoFlat Reno Wohnungsstation mit integrier-
tem Frischwassersystem / Flat station for direct
heating and domestic hot water
Für den Austausch von Gasthermen in Wohnungen und Mehrfamilienhäusern. / For replacement of gas boilers in apartment
buildings and multi-family houses.
Reno
Für den Austausch
von Gasthermen / For
replacement of gas
boilers
Werbung
Inhaltsverzeichnis
Fehlerbehebung
Verwandte Anleitungen für Danfoss EvoFlat Reno
Inhaltszusammenfassung für Danfoss EvoFlat Reno
- Seite 1 Montage- und Betriebsanleitung / Mounting and operating guide EvoFlat Reno Wohnungsstation mit integrier- tem Frischwassersystem / Flat station for direct heating and domestic hot water Für den Austausch von Gasthermen in Wohnungen und Mehrfamilienhäusern. / For replacement of gas boilers in apartment buildings and multi-family houses.
- Seite 2 Trouble shooting DHW supply ................. 19 14.0 Problemlösung Heizung / Trouble shooting HE ......................20 15.0 EU Gutachten / EU Declaration of Conformity ........................ 24 16.0 Inbetriebnahmezertifikat / Commissioning certificate ....................25 2 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02...
-
Seite 3: Allgemeine Sicherheitshinweise
Die Installation ist stets unter Beachtung der landestypis- Niemals die Station an ihrer Frontabdeckung anheben! chen Vorschriften mit Sicherheitsventilen auszustatten. ZIEHEN Sie die Anschlüsse nach dem Transport erneut FEST. AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 3... - Seite 4 Die Station besteht aus Materialien, die nicht zusammen mit dem Hausmüll entsorgt werden dürfen. Bitte zerlegen Sie das Produkt zur entsorgung in Einzelteile und führen Sie sie gemäß den geltenden örtlichen Vorschriften sortenrein der Entsorgung zu. 4 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02...
-
Seite 5: Safety Notes
Check that all hairpins in click connectionsare completely may cause leaks. REMEMBER to retighten. pushed in. The installation must always be equipped with safety valves in accordance with current regulations and local standards. AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 5... - Seite 6 The station consists of materials that must not be disposed of with house- hold waste. Disconnect the entire energy supply and disassemble the prod- uct for disassembly and dispose of it in accordance with local regulations. 6 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02...
- Seite 7 Darstellung eingebaut und regelmäßig gereinigt werden. Anschlüsse: Die Anschlüsse an die Hausinstallation und die Versorgungsleitungen sind mit Gewinde auszuführen. Die internen Anschlüsse der Wohnungsstation sind Click-Fit-Anschlüsse (siehe Punkt 10). AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 7...
- Seite 8 A variety of energy sources, such as oil, gas Authorized personnel only or solar power, could be used as the primary supply to Danfoss substations. Assembly, start-up and maintenance work must be For the sake of simplicity, HS can be taken to mean the primary supply.
-
Seite 9: Elektrische Anschlüsse
The flat station must be connected to 230 V AC and earth. Please note that the EvoFlat Reno is available in 12 versions, 6 of which are equipped with a converter for 24 V output voltage (see page 11 for Code No.). -
Seite 10: Main Components
This constant differential pressure ensures that the thermostatic valves on the radiators work optimally. The EvoFlat Reno Flat Station is prepared for wall-mounting. The existing connections for DHW and DCW as well as supply and return of second- ary heating circuits can be used without major changes, but it is recommended that the connections for the primary hot water flow and return are to lead through the chimney. - Seite 11 **) Stainless steel soldered HEX, 230 V connection ***) Copper soldered HEX, 230 V connection, Transformer for 24V output voltage ****) Stainless steel soldered HEX, 230 V connection, Transformer for 24V output voltage AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 11...
-
Seite 12: Schaltpläne, Beispiele
Sommer Bypass / Summer bypass PWH/ TWA Stellantrieb / TWA actuator ** Anschluss 3/4” (IG Connections 3/4” (IT) PWC/ Vorlauf/ Vorlauf/ Supply Supply Rücklauf/ Rücklauf/ Return return 12 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101... -
Seite 13: Dimensional Sketch
District heating (DH) supply 4. Primärseite (FW-Rücklauf) / District heating (DH) return 5. Kaltwasser (PWC) / Domestic cold water (DCW) 6. Heizungs-Rücklauf (HRL) / Heating (HE) return AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 13... -
Seite 14: Accessories
A white cover PROTO.854 (photo 1) is available as accessory for the EvoFlat Reno flat stations. The back plate of the EvoFlat Reno flat station and the cover are prepared for mounting of the cover. - Please see photo 2 + 3. - Seite 15 The actuator is equipped with a visual position indicator to show the open or closed position of the valve. Air vent The station should be vented during start up. Entlüftung / Air valve AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 15...
- Seite 16 Sensor pocket, energy meter The sensor of the energy meter is mounted in the sensor pockets. The sensor pocket is placed in the strainer. Tauchhülse / Sensor pocket 16 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101...
- Seite 17 After mounting of the energy meter remember to check and tighten all threaded connections. Click-Anschluss Die Klick-Verbindung kann während des Service demontiert werden. Click connection The click connection can be dismantled during service. Click-Anschluss / Click connection AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 17...
-
Seite 18: Wartung
Venting Checking that the system is thoroughly vented. Spare parts can be ordered from Danfoss. Please ensure that any enquiry includes the flat station serial number. 18 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101... -
Seite 19: Allgemeine Fehlersuche
Temperature drop during tapping. Scaling of the plate heat exchanger. Replace – rinse out. Larger DHW flow than the flat station has Reduce DHW flow. been designed for. AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 19... -
Seite 20: Problemlösung Heizung
WQ-Vorlauftemeratur zu niedrig. Defekter Regler. Der Regler reagiert Hersteller der automatischen Steuerung nichtso, wie er dies gemäss Anleitung hinzuziehen oder Regler austauschen. sollte. Schmutzfänger verstopft. Verschluss/Schmutzfänger reinigen. 20 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101... - Seite 21 Prüfen - austausschen. Entsorgung Dieses Produkt sollte vor dem Recycling oder der Entsorgung zerlegt und ggf. in unterschiedliche Materialgruppen sortiert werden. Beachten Sie stets die örtlichen Entsorgungsbestim- mungen. AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 21...
-
Seite 22: Troubleshooting He
Defective controller. The controller does Call in automatic controls manufacturer not react as it should according to the or replace controller. instructions. Strainer clogged. Clean gate/strainer. 22 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101... - Seite 23 Disposal This product should be dismantled and its components sorted, if possible, in various groups before recycling or disposal. Always follow the local disposal regulations. AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 23...
-
Seite 24: Eu Declaration Of Conformity
Montage- und Betriebsanleitung / Mounting and Operating guide EvoFlat Reno 15. EU GUTACHTEN EU DECLARATION OF CONFORMITY 24 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101... -
Seite 25: Commissioning Certificate
To be completed by the installer This plant has been redrawn, adapted and put into operation date: by installer: Datum/Jahre Firmenname (Stempel) AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 25... - Seite 26 Montage- und Betriebsanleitung / Mounting and Operating guide EvoFlat Reno 26 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025 AN33376446555601-000101...
- Seite 27 Montage- und Betriebsanleitung / Mounting and Operating guide EvoFlat Reno AN33376446555601-000101 145X2025 © Danfoss | Produced by Danfoss Redan A/S | 2020.02 | 27...
- Seite 28 AN33376446555601-000101 28 | © Danfoss | Produced by Danfoss Redan A/S | 2020.02 145X2025...