Battery Service Expert PL-C010P Bedienungsanleitung Seite 7

OPERATING INSTRUCTIONS
Automatic charger PL-C010P
Art. No. 911008
INTENDED USE
The product is suitable for charging and maintaining rechargeable 12 V lead-acid batteries (20 - 300 Ah) and 12 V calcium batteries (25 - 100 Ah).
The product can also be used as power supply adapter (13.7 V / 8 A).
Any other use than described before may damage this product; in addition, improper use may result in serious hazards, such as short-circuiting, fire, electrical shock
etc.
DELIVERY CONTENT
Charger
•
Operating instructions
•
Connection adapter with battery terminal
•
Connection adapter with 12 V plug
•
Connection adapter with rings
•
SAFETY INSTRUCTIONS
Please read these instructions completely before using the product for the first time, they contain important information for correct use. The
warranty/guarantee for this product shall be void in the event of damages caused by non-compliance with the operating instructions. We
assume no liability for any consequential damages!
We assume no liability in the event of personal injury or property damage caused by the improper operation and handling of the product or
by the failure to observe the safety information! In such cases the warranty/guarantee expires.
General
• For safety and technical approval reasons (CE), any unauthorized conversion and/or modification of the product is inadmissible.
• The charger may only be operated on mains voltage of 220 – 240 V AC/50/60 Hz.
• The product is no toy. It should be kept away of children.
The product must only be set up, operated and stored in a place which is out of the reach of children. Danger of life!
• The product is only suitable for charging 12 V lead batteries and 12 V calcium batteries. Never try to charge other rechargeable or non-rechargeable
batteries (e.g. NiCd, NiMH, LiPo, Li-ion)! Fire and explosion hazard!
• Maintenance, installation or repair works may only be performed by an expert/qualified workshop. Use only original spare parts for repair work. The
use of any other spare parts may lead to serious damage to property and personal injury!
• Do not leave packing materials unattended. It could become a hazardous toy for children!
If you recognise damages, stop using the charger, bring the product to a qualified workshop or dispose of it in an environmentally compatible manner.
Operation
• The product may only be operated in dry rooms. It may not get humid or wet, otherwise there is a risk of life-threatening electrical shocks.
• The use of the product under unfavourable environmental conditions must be avoided under all circumstances. Unfavourable environmental
conditions include: ambient temperatures above 40°C, flammable gases, solvents, vapours, dust and relative humidity in excess of 80%.
• Never operate the charger in the passenger compartment of vehicles. The charger may not be operated in the presence of flammable materials or
gases.
• Ensure proper ventilation during the operational phase, never cover the charger and/or the connected rechargeable battery.
Never charge lead batteries in containers or in poorly ventilated rooms. Charging lead batteries may lead to the production of explosive gases!
Keep charger and rechargeable battery away from ignition sources or open fire, do not smoke while using charger and rechargeable battery!
Explosion hazard!
• Never start the device immediately after having taken it from a cold into a warm room. Condensation water may be generated leading not only to
malfunctioning, but there is also a risk of perilous electric shock!
Notes on the rechargeable battery
• Please observe any and all safety and charging information of the battery manufacturer.
• Before connecting the battery to be charged to the charger, disconnect it from all consumers and cables (first switch off all consumers!). Please
remember to always disconnect the ground connection from the rechargeable battery first and only then the positive terminal.
Before connecting the rechargeable battery to the consumer(s), disconnect the charger from the rechargeable battery.
Sparking may occur when the rechargeable battery is connected or disconnected. For this reason always provide proper ventilation!
• Observe correct polarity when connecting a rechargeable battery to the charger (red terminal of the charger = plus/+, black terminal of the charger =
minus/-).
• Lead batteries contain aggressive corrosive acids. Avoid eye and skin contact with liquids from the lead battery! Never disassemble lead batteries!
Wash the parts of the skin affected thoroughly with water and soap. If acid enters the eye, immediately flood the eye with running, clear and cool
water! Then seek medical help immediately!
• Never short-circuit rechargeable batteries or toss them into fire; fire and explosion hazard!
- 7 -