Seite 1
Installation Manual ΟΔΗΓΙΕΣ ΕΓΚΑΤΑΣΤΑΣΗΣ Manuale di installazione Manual de instalação Manuel d’installation Installationsmanual Installationsanweisung Asennusohje Manual de instalación Instrukcja instalacji Montage - Instructies РУКОВОДСТВО ПО МОНТАЖУ Hydronic Ceiling Cassette TKW 20-70 ENGLISH DEUTSCH ESPAÑOL ΕΛΛΗΝΙΚA ITALIANO FRANÇAIS SVENSKA PORTUGUÊS SUOMI РУССКИЙ...
Seite 2
ENGLISH “Hydronic Ceiling Cassette” Fan Coil Unit ITALIANO Ventilconvettori “Hydronic Ceiling Cassette” FRANÇAIS Ventiloconvecteurs “Hydronic Ceiling Cassette” DEUTSCH Hydronik-Kassettengeräte ESPAÑOL Unidades Fan Coil tipo“Hydronic Ceiling Cassette” NEDERLANDS Ventilatieconvector “Hydronic Ceiling Cassette” ΕΛΛΗΝΙΚA Τοπικές κλιματιστικές μονάδες "Hydronic Ceiling Cassette" PORTUGUÊS Ventilconvectores “Hydronic Ceiling Cassette” SVENSKA “Hydronic Ceiling Cassette”...
Seite 3
Contents Page Legend ..............................Dimensions and weight........................Nominal data ............................(16) Technical data ............................(17 - 22) Material supplied ..........................(18 - 19) (23) General information .......................... Warnings: avoid ..........................(8) - 25 Installation ............................(9 - 10) - 26 Water connections ..........................
Seite 4
Inhalt Seite Legende ............................... Maße und Gewichte .......................... Nenndaten ............................(16) Technische Daten ..........................(17 - 22) Mitgeliefertes Material ........................(18 - 19) (23) Allgemeine Hinweise ........................Vorsicht: vermeiden… ........................(8) - 55 Installation ............................(9 - 10) - 56 Wasseranschlüsse ..........................
Seite 5
Πεpιεχόμενα σελίδα ΥΠΟΜΝΗΜΑ ............................Διαστάσεις και βάρ ........................... Ονομαστικα δεδομενα ........................(16) Τεχνικά χαρακτηριστικά ........................(17 - 22) Διαθέσιμο υλικό ..........................(18 - 19) (23) Γενικές π ληροφορίες ........................Αποφυγετε............................(8) - 85 Εγκατάσταση ............................. (9 - 10) - 86 Υδραυλικές...
Seite 6
Sisältö Sivu Merk kien selitykset .......................... Mitat ja painot ............................ Nimellistehot ............................(16) Tekniset tiedot ............................ (17 - 22) Toimitukseen kuuluvat tarvikkeet ....................(18 - 19) (23) Yleiset ohjeet ............................. Vältä ..............................(8) - 115 Asennus .............................. (9 - 10) - 116 Vesiliitännät ............................
Seite 7
WITH METALLIC IRY S COANDA DIFFUSER WITH PLASTIC DIFFUSER IRYS COANDA 360 IRYS COANDA 180 TKW20-TKW30-TKW40 WITH METALLIC IRY S COANDA DIFFUSER WITH PLASTIC DIFFUSER IRYS COANDA 360 IRYS COANDA 180 TKW50-TKW60-TKW70 * Weights refer to base units without valve. I pesi si riferiscono ad unità...
Seite 9
Max 2 chiusure Max. 2 louvres closed Max 2 fermetures Max. 2 Luftauslässe geschlossen Máximo dos rejillas cerradas Max. 2 schoepen gesloten Μέγιστο 2 περσίδες Máximo duas grelhas fechadas Max 2 luftspridare stängda Enintään kaksi tuuletusaukkoa Maks. 2 zamknięcia макс. 2 жалюзи закрыты...
Seite 10
Plastic diffuser Plastic diffuser Please refer to the document "AM TKW" for installation instructions of the metallic IRYS COANDA diffuser.
Seite 11
TKW20-TKW30-TKW40 TKW50-TKW60-TKW70 TKW20-TKW30-TKW40 TKW50-TKW60-TKW70...
Seite 12
N : Neutral C : Default contact condensate pump N : Neutral C : Default contact condensate pump L : Phase V : Cooling valve L : Phase V : Cooling valve Lc : Condensate Pump phase V3, V2, V1 : Motor speed Lc : Condensate Pump phase V3, V2, V1 : Motor speed H : Heating...
Seite 15
III IV III IV 230 V ~ 50/60Hz III IV III IV LEGENDA/TABELA III - Parametry elektryczne nagrzewnicy elektrycznej III – (jeśli jest zainstalowana) A = Modele urządzeń B = Moc grzałki elektrycznej LEGENDA/TABELA III - Parametry elektryczne nagrzewnicy elektrycznej III –...
Seite 16
Table / Tabella / Tableau / Tabelle / Tabla / Tabel / Πίνακας II / Tabela / Tabell / Taulukko / Tabela I / Таблица : I LEGEND / TABLE I LEGENDA / TABELLA I LEGENDE / TABLEAU I Nominal data Dati nominali Caractéristiques nominales Watt...
Seite 17
Table / Tabella / Tableau / Tabelle / Tabla / Tabel / Πίνακας II / Tabela / Tabell / Taulukko / Tabela I / Таблица : III TKW20 TKW30 TKW40 TKW50 TKW60 TKW70 Watt 1500 2500 2500 3000 3000 3000 Volt LEGEND / TABLE III LEGENDA / TABELLA III...
Seite 18
III IV Table / Tabella / Tableau / Tabelle / Tabla / Tabel / Πίνακας II / Tabela / Tabell / Taulukko / Tabela I / Таблица : III LEGENDA/TABELA III Условные обозначен_ия / Таблица 111 Parametry elektryczne nagrzewnicy elektrycznej ( jeśli jest zainstalowana) Технические...
Seite 19
IV V Beskrivning Antal lmpiego Tabell IV: Installationsinstruktioner Enhet installation Bifogat material Isolerande ventilhölje (endast på ventiler som fabriksmonterats) Tätningar (endast på ventiler som fabriksmonterats) Ventilisolering Brickor (endast på ventiler som fabriksmonterats) Kuvaus Määrä Käyttö Taulukko IV: Asennusohjeet Sisäyksiköm asennus To i m i t u k s e e n k u u l u v a t Venttiilien erityskuori {vain yksiköt, joissa on tehtaalla asennetut venttiilit) tarvikkeet...
Seite 20
Tabelle V: Betriebs - Grenzwerte Mindest-Wassereintrittstemperatur: + 5°C Maximaler wasserseitiger Druck Wasserkreislauf 1400 kPa (142 m w.c.) Maximal-Wassereintrittstemperatur: + 80°C Mindesttemperatur: 5°C Installation für Feuchtigkeitsniveau muss gemäß Raumluft EN 1397:2011 erfolgen Maximaltemperatur 32°C 230V ~ 50/60Hz Nennspannung, einphasig Stromversorgung min. 207V – max. 253V Spannungsbereich min.
Seite 21
Tabell V: Driftsgränser Min. ingående vattentemperatur: + 5°C Max. tryck på vattensida: Vattenkrets 1400 kPa (142 m c.a.) Max. ingående vattentemperatur: + 80°C Min. temperatur: 5°C Installationen för fuktnivån valideras enligt Rumsluft specifikationen prEN 1397:2011 Max. temperatur: 32°C 230V ~ 50/60Hz Nominell enfas-spänning Huvudkraftmatning min.
• Failure to observe electric safety codes may cause a fire hazard in If Frico controls are NOT used by the installer it is his own responsibility the event of short circuits. to check compliance with the following directives: •...
Installation See fig. 15. control cable (see dimensions); cardboard template • Such device is not accessible to the public. It must be installed at (supplied with the kit) may be of assistance for this operation. least 2.5 m above ground level, unless it is installed inside engine Depending on the type of ceiling the hangers can be fixed as shown rooms or in similar environments.
Water connections To make water connections to the heat exchanger or the valves To drain the unit completely, refer to “SYSTEM DRAINAGE” in use threaded joints and suitable materials that can ensure perfect the Maintenance section. tightness. The unit is provided with inlet and outlet female connections for Checking both 2 and 4 pipe models.
Electrical connections Table X IMPORTANT: fig. fig. fig. Kind of unit fig. 39 • The unit must be installed in compliance with the national standards on plant installation. TKW__AC • All cables for connection to the unit, as well as its accessories, TKW__IR must be H05 VV-F with PCV insulation in compliance with TKW__EC IR...
Low Energy Consumption Fan Motor Low Energy Consumption Fan Motor version NOTE: • The values showed in the table are reported only at the Low Energy TKW…units can ensure a 0% - 100% constant air flow modulation Consumption Fan Motor. It is necessary to add the control input power (and therefore the thermal and refrigerating capacity) thanks to which corresponds to about 5W ("IR Control"), 9W for the pump and the Inverter technology combined with the last generation of high...
Motorized valve and control • The unit control circuit only allows opening of the motorized valve when the fan motor is working. NOTE: • When a lower temperature is required by the thermostats, the The seal efficiency of the valve assembly is factory tested. Any outlet V and H (terminal blocks ref.20) is powered at 230V and system losses are therefore due to an incorrect installation.
Fresh air renewal and conditioned air supply to an adjacent room Fresh air renewal (See fig. 40e) See fig. 44 - 45. • Side knockouts allow connection of fresh air inlet ducts and ducts • The optional supplementary fan for fresh air intake (field supplied) to deliver conditioned air to an adjacent room.
Maintenance and owner's guide Maintenance Cleaning and maintenance operations must be carried out by specially trained personnel. Before performing any service or maintenance operations, turn OFF the main power switch. Note to the installer: To open the unit grille: turn the two screws through 90° (1/4 turn). Filter cleaning by the installer Clean filters in accordance with the actual operating conditions (approximately every 6 months).
Electrical connections addendum REMEMBER: This document is a complement of the manual and it is designed to be used with. 1) Over-current protection WARNING: each unit must be provided with individual dedicated upstream over-current protection (not sup- plied by Manufacturer). Upstream over-current protection for units without heaters FUSE SIZE FUSE SIZE...
Seite 35
WARNING: When connecting power supply it is forbidden to put more than • one wire end per screw clamp terminal with «hook» shape connector Right hook side use is forbidden Green/yellow Blue Brown Blue Blue Green/yellow Blue Brown • one wire end per screw clamp terminal with “U” shape connector (cf. Daisy chain section). Green/yellow Blue Brown...
Seite 36
Producent zastrzega sobie prawo do zmiany danych produktu bez powiadomienia. Main offi ce Frico AB Tel: +46 31 336 86 00 Industrivägen 41 SE-433 61 Sävedalen mailbox@frico.se Sweden www.frico.net For latest updated information and information about your local contact: www.frico.se...