Operation, Precautions - Chicago Pneumatic BRK 25 Sicherheits- Und Betriebsanleitung

BRK 25, 40, 55, 70, 95
DANGER Compressed gas, explosion
hazard
The accumulator is pressurized even when the
hydraulic system is shut off. To dismount the
accumulator without first releasing the nitrogen gas
can cause serious personal injury or death.
► Fill the high-pressure accumulator with nitrogen
(N ) only.
2
Only authorised personnel are qualified to work
►
with the accumulator.
WARNING Hydraulic oil at high
pressure
Thin jets of hydraulic oil under high pressure can
penetrate the skin and cause permanent damage.
► Immediately consult a doctor if hydraulic oil has
penetrated the skin.
Never use your fingers to check for hydraulic fluid
►
leaks.
Keep your face away from any possible leaks.
►
WARNING Hydraulic oil
Spilled hydraulic oil can cause burns, accidents due
to slippery conditions and will also harm the
environment.
Take care of all spilled oil and handle it according
►
to your safety and environmental regulations.
Never dismount the hydraulic machine when the
►
hydraulic oil is hot.
► Never run any hydraulic lines for attachment of
the hydraulic machine through the drivers cab.
CAUTION Skin eczema
Hydraulic oil can cause eczema if it comes in contact
with the skin.
Avoid getting hydraulic oil on your hands.
►
Always use protective gloves when working with
►
hydraulic oil.
► Wash hands after contact with hydraulic oil.
CAUTION Moving parts
Risk for crushed hands and fingers.
Never check bores or passages with hands or
►
fingers.
3392 5166 90 | Original instructions
Safety and operating instructions

Operation, precautions

DANGER Explosion hazard
If an insertion tool comes into contact with
explosives or explosive gases, an explosion could
occur. When working on certain materials and when
using certain materials in machine parts, sparks and
ignition can occur. Explosions will lead to severe
injuries or death.
Never operate the machine in any explosive
►
environment.
Never use the machine near flammable materials,
►
fumes or dust.
► Make sure that there are no undetected sources
of gas or explosives.
WARNING Operating pressure
If the maximum operating pressure for the hydraulic
machine is exceeded, the accumulator can be over
charged which can result in material damage and
personal injury.
► Always run the hydraulic machine with the correct
operating pressure. See "Technical data".
WARNING Unexpected movements
The inserted tool is exposed to heavy strains when
the machine is used. The inserted tool may break
due to fatigue after a certain amount of use. If the
inserted tool breaks or gets stuck, there may be
sudden and unexpected movement that can cause
injuries. Furthermore, losing your balance or slipping
may cause injury.
Make sure that you always keep a stable position
►
with your feet as far apart as your shoulder width,
and keeping a balanced body weight.
Always inspect the equipment prior to use. Never
►
use the equipment if you suspect that it is
damaged.
► Make sure that the handles are clean and free of
grease and oil.
Keep your feet away from the inserted tool.
►
Stand firmly and always hold on to the machine
►
with both hands.
Never start the machine when it is lying on the
►
ground.
Never 'ride on the machine with one leg over the
►
handle.
Never strike or abuse the equipment.
►
7