Safety - Mammuth PT20L095 Bedienungsanleitung

2. Safety

1. Operator should read all warning signs and instruction here and on the pallet truck before using
this truck.
2. Do not operate a hand pallet truck unless you are familiar with it and have been trained or
authorized to do so.
3. Check the device/the machine on missing/loose-fitting parts, deformations and defects BEFORE
EACH USE. In case one of the aforementioned faults is noticed, the device/machine has to be
decommissioned immediately.
4. Do not use the pallet truck on a uneven or slopping ground. Do not use the pallet truck on
gradients.
5. The pallet truck is not allowed to be used in insufficiently illuminated areas. Minimum
illimination must be at least 50 lux.
6. If the pallet truck is moving, it is not allowed to turn the handle into the right angle to stop the
pallet truck.
7. It is forbidden to use hand pallet truck for people transportation.
8. It is not allowed to use the pallet truck as a jack.
9. It is not allowed to use the fork of the pallet truck as a lever to lift loads.
10. Do not load like in figure 6 B
11. Do not load over maximum capacity.
12. It is not allowed to use the pallet truck in risky conditions.
13. It is not allowed to use the pallet truck in direct contact with food.
14. It is not allowed to use the pallet truck in explosive atmosphere.
15. Operator must wear safety boots and gloves.
16. Whilst the goods are being transported all none operational staff should be at
a minimum distance of 600mm.
17. Under any special conditions or environments, the operator should carry out all relevant risk
assessments and method statements before commencing work with the pallet truck
18. It is forbidden to use the pallet truck if there is a risk that the pallet truck and load may fall down,
for example, from unsecured ramps.
.
15