Inhaltszusammenfassung für Praher Plastics AQUASTAR mp6 pos
Seite 1
All manuals and user guides at all-guides.com Zertifiziert nach certified acc. to EN ISO 9001:2008...
Seite 2
All manuals and user guides at all-guides.com INHALTSÜBERSICHT Urheberrecht Vorwort zu Bedienungsanleitung Gewährleistungs- und Haftungsansprüche Arbeitssicherheitshinweise Sicherheitshinweise Restrisiken Gefährdung durch Strom Gefährdung durch menschliches Fehlverhalten Gefährdung durch Strom bei Reinigungsarbeiten Allgemein Bestimmungsgemäße Verwendung Montage Funktions- und Installationsschema für Praher 6-Wege Ventile Elektrischer Anschluss Abmessungen Explosionszeichnung Aquastar MP6 230/24V...
Seite 3
All manuals and user guides at all-guides.com www.praherplastics.com...
Seite 4
All manuals and user guides at all-guides.com Urheberrecht Die Bedienungsanleitung enthält urheberrechtlich geschützte Informationen. Alle Rechte unter Vorbehalt der Praher Plastics Austria GmbH. Die Bedienungsanleitung ist für die Bedienperson bestimmt. Die Vervielfältigung, Reproduktion oder Übersetzung dieser Dokumente in andere Sprachen, ganz oder teilweise, bedarf der ausdrücklichen Genehmigung durch die Praher Plastics Austria GmbH.
Seite 5
All manuals and user guides at all-guides.com Gewährleistungs- und Haftungsansprüche Gewährleistungs- und Haftungsansprüche bei Personen- und Sachbeschädigung sind ausgeschlossen, wenn sie auf einen oder mehrere der folgenden Ursachen zurückzuführen sind. Nicht bestimmungsgemäße Verwendung des Aquastar Unsachgemäßes Montieren, in Betrieb nehmen, Bedienen und Warten des Aquastar ...
Seite 6
All manuals and user guides at all-guides.com Um diesen Zustand zu erhalten und einen gefahrlosen Betrieb sicherzustellen, muss der Anwender die Sicherheitshinweise beachten, die in dieser Bedienungsanleitung enthalten sind. Die Installationsarbeiten dürfen nur von einem befugten und konzessionierten Elektroinstallateur oder Elektrounternehmen durchgeführt werden.
Seite 7
Reinigungsarbeiten am Aquastar dürfen nur im spannungslosen Zustand durchgeführt werden. Allgemein Praher Plastics Austria Aquastar Steuerungen sind hochwertige technische Produkte, die mit großer Genauigkeit und nach modernsten technischen Fertigungsmethoden hergestellt werden. Sollten trotzdem berechtigte Beanstandungen vorhanden sein, werden diese natürlich schnellstmöglich behoben. Für das Gerät gilt eine Gewährleistung nach geltendem EU-Recht.
Seite 8
All manuals and user guides at all-guides.com Montage Geräteinstallation - Installation des Ventils Binden sie das Ventil entsprechend der Beschriftung und der folgenden Skizze in die Rohrleitung ein. Verwenden sie Übergangsverschraubungen. Dichten sie bei Gewindeanschlüssen nur mit Teflonband ab. Das Gerät ist zwar in jeder Lage funktionsfähig, darf jedoch nicht mit dem Stellantrieb nach unten montiert werden.
Seite 9
All manuals and user guides at all-guides.com 10 Elektrischer Anschluss Motor S1 - Endschalter GESCHLOSSEN S2 - Endschalter FILTERN S3 - Endschalter RÜCKSPÜLEN S4 - Endschalter NACHSPÜLEN S5 - Endschalter ENTLEEREN S6 - Endschalter PUMPE S7 - Endschalter ZIRKULIEREN Motor nur bei 3"...
Seite 10
All manuals and user guides at all-guides.com 11 Abmessungen 1 ½“ 2“ 3“ 99,5 29,5 85,5 61,5 163,5 87,5 www.praherplastics.com...
Seite 11
All manuals and user guides at all-guides.com 12 Explosionszeichnung Aquastar MP6 230/24V 2. Motor nur bei MP6 3“ 1. Schauglas + O-Ring 2. Deckel für Superstar 3. SK-Schraube 4. Notgriff 5. Ventildeckel 6. O-Ring - Gehäuse- deckel 7. Ventil 8. Platine 9.
Seite 12
All manuals and user guides at all-guides.com 13 Handnotbetätigung Einsatz bei Stromausfall oder Steuerungsproblemen 1. Vor jeder Betätigung der Handnot, Ventil von Stromkreis trennen Steuerkabel zum Ventil unterbrechen 2. Systemdruck im Ventil absenken (Pumpe abschalten, auf eventuell vorhandene Wassersäulen achten und Kugelhähne schließen) 3.
Seite 13
All manuals and user guides at all-guides.com 15 Montage Achtung: Bei der Montage des Aquastar ist die Mittelschraube (Bild 7) mit minimal 10Nm anziehen damit keine Fehlfunktion auftreten kann und das Schauglas (Bild 9) handfest anziehen um die Dichtheit des Aquastar MP6 zu gewährleisten! www.praherplastics.com...
Seite 14
All manuals and user guides at all-guides.com 16 Fehlerbehebung Antrieb dreht ständig im Kreis ohne eine Position anzufahren o Gerät wurde zugehörigen Ventil Zur Reparatur senden da in diesem Fall bereits ein Defekt vorliegt Teller hebt schwer oder Antrieb läuft unregelmäßig bzw. Strömungsgeräusche sind zu vernehmen o Die Pumpe wird beim Anheben des Ventiltellers nicht ausgeschaltet ...
Seite 15
All manuals and user guides at all-guides.com Notizen www.praherplastics.com...
Seite 16
All manuals and user guides at all-guides.com Table of Contents Copyrights Introduction to operation manual Warranty and liability Instructions for safety at work Safety instructions Residual Risk Hazard generated by current Hazard generated by human error Hazard generated by current during cleaning work General Directions for use Assembly...
Seite 17
All manuals and user guides at all-guides.com www.praherplastics.com...
Seite 19
All manuals and user guides at all-guides.com Warranty and liability Warranty and liability claims in the context of damage to person or property shall be excluded where such damage results from one or several of the causes listed below: Improper use of the Aquastar ...
Seite 20
All manuals and user guides at all-guides.com This equipment is not intended for it by persons (including children) with reduced physical, sensory or mental abilities or for lack of experience and/or for lack of knowledge to be used it is, it by a person responsible for their security is supervised or received from it instructions, how the equipment is to be used.
Seite 21
All manuals and user guides at all-guides.com Residual Risk 6.1 Hazard generated by current Manipulation of the Aquastar by operating staff is strictly prohibited and may only be performed by duly authorized staff, qualified for electrical work. Compliance with the corresponding instruction and prohibition signs is required.
Seite 22
All manuals and user guides at all-guides.com Assembly Device installation – installation of the valve Install the valve in the conduit according to the labeling and the sketch below. Use adapter unions. Threaded connections should be sealed only with Teflon strip. Although the device is functional in any position, it must not be installed with the actuator facing down.
Seite 23
All manuals and user guides at all-guides.com 10 Connection diagram Motor S1 .. Limit switch CLOSED S2 .. Limit switch FILTER S3 .. Limit switch BACKWASH S4 .. Limit switch RINSE S5 .. Limit switch WASTE S6 .. Limit switch PUMP S7 ..
Seite 24
All manuals and user guides at all-guides.com 11 Dimensions 1 ½“ 2“ 3“ 99,5 29,5 85,5 61,5 163,5 87,5 www.praherplastics.com...
Seite 25
All manuals and user guides at all-guides.com 12 Exploded view drawing Aquastar MP 230/24V motor only in MP6 3“ 1. inspection glas + O-ring 2. cover for Aquastar 3. screw 4. emergency grip 5. Valve cover 6. O-ring 7. Valve 8.
Seite 26
All manuals and user guides at all-guides.com 13 Emergency handle In case of power loss or control problems: 1. Prior to using the emergency handle disconnect the valve from the power supply. Interrupt the control cables to the valve. 2. Lower the system pressure (switch off pump, close ball valves, mind possible water columns) 3.
Seite 27
All manuals and user guides at all-guides.com 15 Installation Attention: During installation screw tight the centre screw with a minimum torque of 10Nm (pict 7) to secure the functionality and screw the sight glass hand-tight in the lid (pict. 9) in order to secure tightness of the Aquastar mp6 www.praherplastics.com...
Seite 28
All manuals and user guides at all-guides.com 16 Troubleshooting The drive rotates continually without approaching a position o Device was driven without matching valve Please return for repair; damage has already occurred in this case The disk is not lifting freely, or the drive is not running smoothly, or flow noises can be heard o The pump does not switch off on lifting the valve disk ...
Seite 29
All manuals and user guides at all-guides.com Notes Notizen www.praherplastics.com...
Seite 30
All manuals and user guides at all-guides.com Notes Notizen www.praherplastics.com...
Seite 31
All manuals and user guides at all-guides.com Notes Notizen www.praherplastics.com...
Seite 32
All manuals and user guides at all-guides.com...