Werbung
Verfügbare Sprachen
Verfügbare Sprachen
BM series spiral mixers are a new type of kneader. Both the dough arm and bowl are running to be able to raise the mixing
speed and efficiency greatly. The machines are equipped with a protective cover, are easy to operate and safe. They are good
looking and easy to clean, suitable for mixing flour in hotels, restaurants and public canteens.
Technical specifications
Model
Voltage
7455.1430
~230
7455.1435
~230
Operation and Notes
1.
Set it on a dry horizontal plane (or support), place it firmly.
2.
Before use, ensure that the power supply corresponds to that required by the machine and that the external ground
wire is reliably connected.
3.
Ensure that flour mixing capacity is lower than the max. flour capacity.
4.
Before starting, ensure that the protective cover has been put down.
5.
Do not put hands and hard-things into the bowl while it runs.
6.
Do not hold and drag the belts and chains by hand.
Maintenance
1.
Continuous run time is not too long, keep using the machine.
2.
After use, clean the machine, as to avoid bacteria growth.
3.
The transmission case is packed with special grease that will last for six months of service. To add or replace grease,
it is necessary to remove the upper cover.
Note: Before maintenance, the machine must be cut off from the power supply.
Troubleshooting
Problem
The mixing shaft does not rotate after
being switched on
Square rod trembles
Temperature rise of motor is too high,
low speed
The noise of the transmission case is
loud
The agitator knocks against the bowl
Warning: It cannot be cleaned with water directly.
Frequency
Power
Rating
50Hz
1.1 kW
50Hz
1.5 kW
Probable cause
Electric connectors are loose
Lock bolts are loose
Lack of voltage
Overload
Lubrication is insufficient
Chains are loose
The agitator or bowl is deformed
www.combisteel.com
IP
Bowl
Dough max.
volume
quantity
IPX1
20
8 kg
IPX1
30
12 kg
Check the electric circuit, tighten those loose
connectors
Tighten those bolts
Check the supply voltage
Load it less
Add or replace the grease
Tighten the chains
Repair or replace deformed part
Dimension
Net
(a×b×c) mm
weight
736x381x685
109 kg
778x432x750
119 kg
Remedy
3
Werbung
Fehlerbehebung
