Toyota PW5D0-10004 Montageanleitung
Toyota c-hr
Quicklinks
Toyota C-HR
Towbar wiring kit 13-pin
Towbar wiring kit 7-pin
Installation Instructions
Model year:
Vehicle code:
Part number:
Manual reference number: AIM 004 565-4
As from 2019/10
NGX10*-AH**XW
NGX50*-AH**XW
MAXH10*-AHX*BW
ZYX1**-AHX*BW
PW5D0-10004
PW5D0-10005
PW501-00583
PW501-00584
13 Pin Towbar wiring kit
7 Pin Towbar wiring kit
Scotchlock (Qty' 1)
Scotchlock (Qty' 1)
Verwandte Anleitungen für Toyota PW5D0-10004
Inhaltszusammenfassung für Toyota PW5D0-10004
- Seite 1 Toyota C-HR Towbar wiring kit 13-pin Towbar wiring kit 7-pin Installation Instructions Model year: As from 2019/10 Vehicle code: NGX10*-AH**XW NGX50*-AH**XW MAXH10*-AHX*BW ZYX1**-AHX*BW Part number: PW5D0-10004 13 Pin Towbar wiring kit PW5D0-10005 7 Pin Towbar wiring kit PW501-00583 Scotchlock (Qty’ 1) PW501-00584 Scotchlock (Qty’...
- Seite 2 DISCLAIMER ■ Expert Fitment Required. ■ Montage durch Fachwerkstatt erforderlich. ■ Disconnect the battery earth cable. ■ Massekabel von Batterie abklemmen. ■ T o avoid damage to the wiring harness, ensure contact ■ Z ur Vermeidung von Beschädigungen an der abelisolation with sharp edges is prevented. ist Berührung mit scharfen Kanten zu vermeiden. ■ Install parts as shown on illustrations. ■ Teile gemäß Abbildung montieren. ■ Re-connect battery. ■ Batterie wieder anschließen. ■ R e-fit panels, ensure that the wiring harness and other ■ P aneele wieder anbringen; achten Sie darauf, dass der components are neatly and securely located. Kabelbaum und andere Teile ordnungsgemäß und genau positioniert sind. ■ Montaje sólo por el concesionario. ■ Montage par spécialiste nécessaire.
- Seite 3 DISCLAIMER ■ A szereléshez szakműhely kell. ■ Konieczny montaż przez warsztat specjalistyczny. ■ Húzza le az akkumulátor testkábeljét. ■ Odłączyć przewód masy od akumulatora. ■ A kábelszigetelés megsérülésének elkerülésére ügyeljen ■ D la zapobieżenia uszkodzeniu izolacji chronić przed arra, hogy a kábel ne juthasson érintkezésbe éles peremű zetknięciem z ostrymi krawędziami. alkatrészekkel. ■ Zamontować części zgodnie z rysunkiem. ■ Az alkatrészeket az ábrák szerint szerelje be. ■ Ponownie podłączyć akumulator. ■ Ismét csatlakoztassa az akkumulátort. ■ N a powrót osadzić osłony; zadbać aby wiązka kablowa i ■ S zerelje vissza a fedőlapokat, ügyeljen arra, hogy a ábelek inne części były właściwie i dokładnie ułożone. és a többi alkatrészek pontosan a számukra kijelölt helyen maradjanak. ■ Η τοποθέτηση να γίνει ΜΟΝΟ από εξουσιοδοτημένο ■ Монтаж должны выполнять специалисты в мастерской...
- Seite 4 WIRE COLOUR TABLE Blue Blau Azul Bleu Azul Blauw Blå Blå Blå Sininen Modrá Black Schwarz Negro Noir Nero Preto Zwart Sort Sort Svart Musta Černá Brown Braun Marrón Marron Marrone Castanho Bruin Brun Brun Brun Ruskea Hnědá Azul Bleu Azul- Donker- Tummansin-...
- Seite 5 Revision record Rev. No. Date Page Step Remarks 10.12.2019 Updated 10.12.2019 22-25 22-26, 28 Updated 10.12.2019 39-40 Updated 18.01.2021 Tools Tools added 18.01.2021 23, 37 24, CS Delta „S“ added to eath point. 18.01.2021 Checks added. Tools, 31, 28.05.2021 8, 28, 30, 38 Tools updated 33,CS 35A, 35B,...
- Seite 6 KIT CONTENT PW5D0-10004 (13 Pin) CHECK SHEET 20 Amp. LowProf mini 90982 -09023 Manual reference number: AIM 004 565-4 6 of 44...
- Seite 7 KIT CONTENT PW5D0-10005 (7 Pin) CHECK SHEET 20 Amp. LowProf mini 90982 -09023 Manual reference number: AIM 004 565-4 7 of 44...
- Seite 8 FITTING PARTS PW501-00583 PW501-00584 for Hybrid (scotchlock 0.35 mm to 1.25 mm for Conventional (scotchlock 0.75 mm to 2 mm TOOL / CONSUMABLES / PPE 8 mm 10 mm CLICK 10 mm PZ415-0JGB9-00 4 mm AIM 003-516-* F595 AIM 006 006-* DIAGNOSTIC TOOL MIN.
-
Seite 9: Installation Instructions
WIRE HARNESS OVERVIEW INSTALLATION INSTRUCTIONS 10mm 90 sec Manual reference number: AIM 004 565-4 9 of 44... - Seite 10 Masking Tape 10mm Manual reference number: AIM 004 565-4 10 of 44...
- Seite 11 10mm 10mm Manual reference number: AIM 004 565-4 11 of 44...
- Seite 12 Manual reference number: AIM 004 565-4 12 of 44...
- Seite 13 TYRE REPAIR KIT (LOW BOARD) Manual reference number: AIM 004 565-4 13 of 44...
- Seite 14 FULL SPARE WHEEL Manual reference number: AIM 004 565-4 14 of 44...
- Seite 15 TYRE REPAIR KIT (MID BOARD) Manual reference number: AIM 004 565-4 15 of 44...
- Seite 16 10 mm CHECK SHEET Masking Tape 10 mm 1.2/1.8 Engine ONLY Manual reference number: AIM 004 565-4 16 of 44...
- Seite 17 Click Click Manual reference number: AIM 004 565-4 17 of 44...
- Seite 18 13 PIN ONLY CHECK SHEET 15 Amp. 15 Amp. CHECK SHEET For 7 pin only 8 mm 4 mm Manual reference number: AIM 004 565-4 18 of 44...
- Seite 19 HORIZONTAL DETACHABLE ONLY VERTICAL DETACHABLE ONLY Manual reference number: AIM 004 565-4 19 of 44...
- Seite 20 OE - 10 Pin Click OE - 10 Pin OE - 10 Pin Manual reference number: AIM 004 565-4 20 of 44...
- Seite 21 HORIZONTAL DETACHABLE ONLY VERTICAL DETACHABLE ONLY Manual reference number: AIM 004 565-4 21 of 44...
- Seite 22 Click Click 13 PIN ONLY Manual reference number: AIM 004 565-4 22 of 44...
- Seite 23 13 PIN ONLY CHECK SHEET 13 PIN ONLY CLICK Y1(OE) 10 mm 9 Nm Click Click Click Y1(OE) Manual reference number: AIM 004 565-4 23 of 44...
- Seite 24 13 PIN ONLY 13 PIN ONLY 13 PIN ONLY 13 PIN ONLY Manual reference number: AIM 004 565-4 24 of 44...
- Seite 25 WITH EPB ECU CHECK SHEET WITHOUT EPB ECU CLICK 10mm 9 Nm Manual reference number: AIM 004 565-4 25 of 44...
- Seite 26 Click Click “Keep harness aside the OE harness” Manual reference number: AIM 004 565-4 26 of 44...
- Seite 27 CHECK SHEET Hotspot Hotspot Manual reference number: AIM 004 565-4 27 of 44...
- Seite 28 Hotspot CHECK SHEET PZ415-0JGB9-00 F595 OE-12 Pin WIRE SIDE VIEW Signal Color PIN 1 Click Manual reference number: AIM 004 565-4 28 of 44...
- Seite 29 Hotspot Manual reference number: AIM 004 565-4 29 of 44...
- Seite 30 CHECK SHEET 13 PIN ONLY PZ415-0JGB9-00 F595 OE-12 Pin WIRE SIDE VIEW Signal Color PIN 1 Click Manual reference number: AIM 004 565-4 30 of 44...
- Seite 31 CHECK SHEET 13 PIN ONLY Manual reference number: AIM 004 565-4 31 of 44...
- Seite 32 13 PIN ONLY Electrical Tape For Conv. For Hybrid For Conv. For Hybrid For Conv. For Hybrid For Conv. For Hybrid Electrical Tape For Conv. For Hybrid Manual reference number: AIM 004 565-4 32 of 44...
- Seite 33 HYBRID PW501-00583 (for 0.35mm Wire range (mm OE wire Min. Max. OE wire 0,35 Accessory wire Accessory wire 0,35 Vehicle wire 40 mm Electrical Tape Click TOP VIEW REAR Manual reference number: AIM 004 565-4 33 of 44...
- Seite 34 CONV. PW501-00584 (for 2mm Wire range (mm OE wire Min. Max. OE wire 0,75 Accessory wire Accessory wire 0,75 Vehicle wire 40 mm Click Electrical Tape Manual reference number: AIM 004 565-4 34 of 44...
- Seite 35 CHECK SHEET 1.2L Vehicle Manual reference number: AIM 004 565-4 35 of 44...
- Seite 36 CHECK SHEET 1.8L Hybrid Vehicle Manual reference number: AIM 004 565-4 36 of 44...
- Seite 37 CHECK SHEET 2.0L Vehicle CLICK CHECK SHEET CHECK SHEET OWNERS MANUAL OWNERS MANUAL Toyota C-HR Towing hitch wire Toyota C-HR Towing hitch wire Model /Year Model /Year As from 2019/10 harness 7 pin/13 pin As from 2019/10 harness 7 pin/13 pin 10 mm 1.2L Vehicle...
- Seite 38 CHECK SHEET Page 1 of 5 Model/Year Toyota C-HR Towbar wiring kit 13-pin As from 2019/10 Towbar wiring kit 7-pin VIN n° DURING INSTALLATION P/N = OK 13 PIN ONLY 15 Amp. 15 Amp. Click Click (3x) Serial Number 9 Nm...
- Seite 39 Page 2 of 5 DURIG INSTALLATION Hotspot PZ415-0JGB9-00 F595 OE-12 Pin WIRE SIDE VIEW Signal Color PIN 1 Click 13 PIN ONLY PZ415-0JGB9-00 F595 OE-12 Pin WIRE SIDE VIEW Signal Color PIN 1 Click Manual reference number: AIM 004 565-4 39 of 44...
-
Seite 40: After Installation
Page 3 of 5 AFTER INSTALLATION 1.2L Vehicle 1.8L Hybrid Vehicle 2.0L Vehicle Manual reference number: AIM 004 565-4 40 of 44... - Seite 41 Page 4 of 5 AFTER INSTALLATION 7 Pin s t o p 13 Pin s t o p s t o p s t o p s t o p Manual reference number: AIM 004 565-4 41 of 44...
-
Seite 42: Installation Date
ENGINE START STOP FAILURE TEST FUNCTION Beeeeeeep NO DTC=OK OWNERS MANUAL OWNERS MANUAL Toyota C-HR Towing hitch wire Toyota C-HR Towing hitch wire Model /Year Model /Year As from 2019/10 harness 7 pin/13 pin As from 2019/10 harness 7 pin/13 pin 1.2L Vehicle... - Seite 43 OWNER’S MANUAL Toyota C-HR Towing hitch wire Model /Year As from 2019/10 harness 7 pin/13 pin Adapter Adapter Manual reference number: AIM 004 565-4 43 of 44...
- Seite 44 OWNER’S MANUAL Toyota C-HR Towing hitch wire Model /Year As from 2019/10 harness 7 pin/13 pin 1.2L Vehicle 1.8L Hybrid Vehicle 2.0L Vehicle Manual reference number: AIM 004 565-4 44 of 44...