Safety Instructions; Device Elements; Symbols On The Machine - Kärcher IVM 60/30 M Z22 Originalbetriebsanleitung

– Vacuum only using all the filter elements; other-
wise, the suction motor can get damaged and this
can be hazardous to health on account of in-
creased release of fine dust particles!
– Please follow the safety regulations applicable to
the materials to be sucked in. During proper/im-
proper operation parts of the appliance can reach
temperatures of up to 125 °C.
– You are not allowed to use an extension cable.
WARNING
This appliance should not be used or stored in the open
under wet conditions.

Safety instructions

Switch off the appliance after completing the work and
pull out the mains plug.
Observe the safety regulations for the materials be-

ing vacuumed.
In Emergency
In case of emergency (while sucking in combustible ma-
terials, when there is a short-circuit or some other elec-
trical defect), switch off the appliance and remove the
plug from the socket.

Device elements

1 Torque motor
2 Suction head
3 Intermediate ring
4 Floor nozzle holder
5 Filter vibrator
6 Washer ring
7 Filter
8 Suction support
9 Stopper
10 Coupling for pressure balancing
11 Container handle
12 Dirt receptacle
13 Pressure equalisation
14 Filter ring
15 Intermediate ring lock
16 Lever for the filter cleaning
17 Rotating knob
18 Pilot lamp "negative pressure"
19 Pilot lamp "phase and rotary field fault"
20 "Ready for use" indicator lamp
21 Suction head lock
22 Push handle
23 Chassis
24 Steering roller
25 Spring bow for earthing
26 Cable clamp
27 Holder for suction pipe
28 Handle of the suction head
29 Power cord
30 Nameplate
31 Exhaust muffler

Symbols on the machine

Do not suck in any ignition sources!
Suitable for suction of combustible
dusts of the dust explosion classes in
Zone 22.
12
M
WARNING: This unit contains hazardous dust. Empty-
ing and maintenance, including the removal of the dust
bag, may only be carried out by someone who is famil-
iar with the unit and wearing suitable protective gear.
Do not switch on the unit until the complete filter sys-
tem has been installed and the function of the volume-
flow control has been tested.
The label displays the permissible filters and dust bags
for this device.
Filter
Order No.
Dust disposal bag
Order No.
WARNING
Do not vacuum without the filter elements; otherwise,
the suction motor can get damaged and this can be haz-
ardous to health on account of increased release of fine
dust particles.
Note: Additional regulations can be applicable to dusts
with an ignition capacity below 1mJ.
 Bring the appliance to working position - secure it,
if required, with parking brakes.
 Insert the suction hose (not included) into the suc-
tion hose connection.
 Check the fill level in the dirt container prior to start-
ing work and empty the container if necessary.
 Ensure that the dirt container has been inserted
properly. Spring bows must be clean and lie flat
against the dirt container. Clean spring bow with a
moist cloth, as necessary.
 Attach the desired accessories (not included).
– 2
EN
M
!
9.439-542.0
9.989-606.0
9.439-542.0
9.989-606.0
Start up