Seite 1
TX-W32D5DPF Service Manual Safety Service Support Specifications Service and repair of Block Diagrams this product is Parts List supported by Panasonic's LUCI Service interface. Information This interface provides a Adjustments link between the TV and a standard PC to allow a...
Seite 2
Audio Control Power supply Video BACK D - PCB E - PCB D - Schematic E - Schematic F - PCBs G - PCB F - Schematic G - Schematic H - PCB K - PCB H - Schematic K - Schematic M - PCB Y - PCBs M - Schematic...
Seite 3
ORDER No. SM-98048 Colour Television TX-W32D5DPF EURO - 5 Chassis SPECIFICATIONS TECHNISCHE DATEN Power Source: 220-240V AC, 50Hz Netzpannung: 220-240V AC, 50Hz Power Consumption: 199W Leistungsaufnahme: 199W Aerial Impedance: 75Ω unbalanced, Coaxial Type Antennenimpedanz: 75Ω asymmetrisch, Koaxial-Typ Standby Power Consumption:...
CONTENTS INHALT SAFETY PRECAUTIONS ............ 2 SICHERHEITSVORKEHRUNGEN ........2 SERVICE HINTS ..............4 SERVICE HINWEISE ............4 SERVICE POSITION ............5 SERVICEPOSITION ............5 SELF CHECK ..............6 SELBSTDIAGNOSE ............6 ADJUSTMENT PROCEDURE ..........7 ABGLEICH ................7 WAVEFORM PATTERN TABLE .......... 8 SIGNAL TABELLE...............
Seite 5
LEAKAGE CURRENT HOT CHECK MESSUNG DES KRIECHSTROMS IM EINGESCHALTETEN ZUSTAND Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check. Den Netzstecker direkt in eine Netsteckdose stecken. Connect a 2kΩ 10W resistor in series with an Für diese Messung keinen Trenntransformator exposed metallic part on the receiver and an earth, verwenden.
SERVICE HINTS SERVICE HINWEISE HOW TO REMOVE THE REAR COVER ENTFERNEN DER GERÄTERÜCKWAND Remove the 10 screws as shown in Fig.2. Die 10 Schrauben entfernen, siehe Abb.2. Screws Schrauben Fig.2. Abb.2. LOCATION OF CONTROLS LAGE DER EINSTELLREGLER Y - Board Focus Fokusregler Screen...
How to move the chassis into Comment placer le chassis en position Service position Service Hold and lift the rear of the chassis and gently pull Das Chassis am hinteren Ende leicht anheben und nach the chassis toward you, as shown in Fig.4. hinten herausziehen, wie in Abbildung 4 dargestellt.
SELF CHECK SELBSTDIAGNOSE Self-check is used to automatically check the bus Die Selbstdiagnose dient zum automatischen Prüfen lines and hexadecimal code of the TV set. der Bus-Leitungen sowie des Hexadezimalcodes des FS-Geräts. Zum Umschalten auf Selbstdiagnose To get into the Self-Check mode press the down zunächst die Taste "STATUS"...
WAVEFORM PATTERN TABLE SIGNAL TABELLE NOTE: All waveforms have been taken using a standard colour bar pattern. HINWEIS: Alle oszillogramme wurden unter Verwendung des Standard Farbbalken Testbildes aufgenommen. Vert Drive VFLB Vert Out IC451 Pin 2 IC451 Pin 5 IC601 Pin 1 8.6mS 8.6mS H - Out...
ALIGNMENT SETTINGS: (The figures below are nominal and used for representative purposes only.) 1. Set the Bass to maximum position, set the Treble to minimum position, press the down button (- / v) on the customer controls at the front of the TV and at the same time press the INDEX button on the remote control, this will place the TV into the Service Mode.
ABGLEICHTABELLE: (Die angegebenen Werte sind Mittelwerte und Können individuell nach oben oder unten nach dem korrekten Abgleich abweichen.) 1. Um in den Service-Mode zu gelangen, gehen sie bitte wie folgt vor. 2. Stellen sie im Toneinstellungs-Menü die Bässe auf Maximun und die Höhen auf Minimum. 3.
PARTS LOCATION EXPLOSIONSZEICHNUNG NOTE: Anmerking: The numbers on the exploded view below Die Nummer auf den mechanischen Teilen refer to the mechanical section of the Zeigt die Bezugsnummer der Ersatzteilliste Replacement Parts List.
Seite 19
Cct Ref Parts Number Description Cct Ref Parts Number Description IC2351 AN7108 H.P. AMPLIFIER D618 MTZJT-779.1C DIODE IC2401 AN6554NSF-E2 OPERATIONAL AMPLIFIER D620 MA165TA5 DIODE IC2402 BA15218F-E2 AMPLIFIER D651 MA165TA5 DIODE IC2501 DPL3519APOA1 DOLBY PROCESSOR D701 AU02V0 DIODE IC2551 STR10006-S POWER SUPPLY D702 MA29TA5 DIODE...
Seite 20
Cct Ref Parts Number Description Cct Ref Parts Number Description D2555 EU02 DIODE Q801 2SK1365LB106 TRANSISTOR D2556 EG01CV0 DIODE Q803 2SD965-R TRANSISTOR D2558 EU02 DIODE Q804 2SA719-TA TRANSISTOR D2559 RU4AMLF-M1 DIODE Q845 2SA684R TRANSISTOR D2611 MA165TA5 DIODE Q846 BC847B TRANSISTOR D2616 MA165TA5 DIODE...
Seite 21
Cct Ref Parts Number Description Cct Ref Parts Number Description Q2307 BC860B TRANSISTOR L005 TLT100K991R COIL Q2308 BC860B TRANSISTOR L007 EXCELDR35V COIL Q2351 BC847B TRANSISTOR L008 ELJFC2R2KF COIL Q2352 BC847B TRANSISTOR L009 ELJFC2R2KF COIL Q2401 BC847B TRANSISTOR L351 TAXK0036 DELAY LINE Q2407 BC847B TRANSISTOR...
Seite 22
Cct Ref Parts Number Description Cct Ref Parts Number Description L1528 EXCELDR35V COIL L3411 TLT015K991R COIL L1529 EXCELDR35V COIL L3412 TLT015K991R COIL L1532 EXCELDR35V COIL L3413 TLT015K991R COIL L1533 EXCELDR35V COIL L3801 EXCELDR35V COIL L1534 EXCELDR35V COIL L3803 EXCELDR35V COIL L1535 EXCELDR35V COIL...
Seite 23
Cct Ref Parts Number Description Cct Ref Parts Number Description JSE025 ERJ6GEY0R00 S.M.CARB 0.1W R262 ERJ6GEYJ103 S.M.CARB 0.1W JSE026 ERJ6GEY0R00 S.M.CARB 0.1W R263 ERJ6GEYJ104 S.M.CARB 0.1W 100K JSE032 ERJ6GEY0R00 S.M.CARB 0.1W R264 ERJ6GEYJ473 S.M.CARB 0.1W JSF001 ERJ6GEY0R00 S.M.CARB 0.1W R265 ERDS1TJ2R2 CARBON 0.5W...
Seite 24
Cct Ref Parts Number Description Cct Ref Parts Number Description R554 ERX3FJR39H METAL R679 ERJ6GEYJ103 S.M.CARB 0.1W R556 ERDS1TJ223 CARBON 0.5W R680 ERJ6GEYJ273 S.M.CARB 0.1W R557 ERDS1TJ683 CARBON 0.5W R681 ERJ6GEYJ103 S.M.CARB 0.1W R558 ERDS1TJ273 CARBON 0.5W R682 ERJ6GEYJ103 S.M.CARB 0.1W R560 ERJ6GEYJ123...
Seite 25
Cct Ref Parts Number Description Cct Ref Parts Number Description R902 ERJ6GEYJ562 S.M.CARB 0.1W R1129 ERJ6GEYJ472 S.M.CARB 0.1W R903 ERJ6GEYJ562 S.M.CARB 0.1W R1130 ERJ6GEYJ104 S.M.CARB 0.1W 100K R904 ERJ6GEYJ102 S.M.CARB 0.1W R1131 ERJ6GEYJ101 S.M.CARB 0.1W R906 ERJ6GEYJ153 S.M.CARB 0.1W R1132 ERJ6GEYJ101 S.M.CARB 0.1W...
Seite 26
Cct Ref Parts Number Description Cct Ref Parts Number Description R1503 ERJ6GEYJ332 S.M.CARB 0.1W R1576 ERJ6GEYJ102 S.M.CARB 0.1W R1504 ERJ6GEYJ151 S.M.CARB 0.1W R1577 ERJ6GEYJ102 S.M.CARB 0.1W R1505 ERJ6GEYJ471 S.M.CARB 0.1W R1578 ERJ6GEYJ301 S.M.CARB 0.1W R1506 ERJ6GEYJ271 S.M.CARB 0.1W R1579 ERJ6GEYJ431 S.M.CARB 0.1W R1507...
Seite 27
Cct Ref Parts Number Description Cct Ref Parts Number Description R1662 ERJ6GEYJ223 S.M.CARB 0.1W R1848 ERJ6GEYJ471 S.M.CARB 0.1W R1663 ERJ6GEYJ331 S.M.CARB 0.1W R1849 ERJ6GEYJ471 S.M.CARB 0.1W R1664 ERJ6GEYJ103 S.M.CARB 0.1W R1850 ERJ6GEYJ471 S.M.CARB 0.1W R1665 ERJ6GEYJ471 S.M.CARB 0.1W R1851 ERJ6GEYJ471 S.M.CARB 0.1W R1666...
Seite 28
Cct Ref Parts Number Description Cct Ref Parts Number Description R2362 ERJ6GEYJ103 S.M.CARB 0.1W R2503 ERJ6GEY0R00 S.M.CARB 0.1W R2363 ERJ6GEYJ103 S.M.CARB 0.1W R2504 ERJ6GEYJ222 S.M.CARB 0.1W R2364 ERD25TJ101 CARBON 0.25W R2508 ERJ6GEYJ471 S.M.CARB 0.1W R2365 ERJ6GEYJ102 S.M.CARB 0.1W R2509 ERJ6GEYJ471 S.M.CARB 0.1W R2368...
Seite 29
Cct Ref Parts Number Description Cct Ref Parts Number Description R2661 ERJ6GEY0R00 S.M.CARB 0.1W R3057 ERJ6GEYJ151 S.M.CARB 0.1W R2662 ERJ6GEYJ681 S.M.CARB 0.1W R3058 ERJ6GEYJ104 S.M.CARB 0.1W 100K R2663 ERJ6GEYJ223 S.M.CARB 0.1W R3059 ERJ6GEYJ102 S.M.CARB 0.1W R2664 ERX12SJW1R0E METAL R3060 ERJ6GEYJ471 S.M.CARB 0.1W R2670...
Seite 30
Cct Ref Parts Number Description Cct Ref Parts Number Description R3423 ERJ6GEYJ470 S.M.CARB 0.1W R3957 ERD25TJ104 CARBON 0.25W 100K R3424 ERJ6GEYJ101 S.M.CARB 0.1W R3958 ERD25TJ104 CARBON 0.25W 100K R3425 ERJ6GEYJ221 S.M.CARB 0.1W R3959 ERD25TJ104 CARBON 0.25W 100K R3426 ERJ6GEYJ680 S.M.CARB 0.1W R3960 ERJ6GEYJ622...
Seite 31
Cct Ref Parts Number Description Cct Ref Parts Number Description 220nF 100nF C268 ECQM1H224J FILM C613 ECUV1H104ZFX S.M. CAP 47µF 100nF C269 ECA1HM470GB ELECT C614 ECUV1H104ZFX S.M. CAP 220nF 100nF C270 ECQM1H224J FILM C615 ECJ2VB1C104K ELECT 350V 220nF 100nF C271 ECQM1H224J FILM C616...
Seite 32
Cct Ref Parts Number Description Cct Ref Parts Number Description 470µF 1µF C857 ECA1EM471GB ELECT C1508 ECEA1HN010UB ELECT 270µF 100nF C858 ECOS2EA271BB ELECT 250V C1509 ECUV1H104ZFX S.M. CAP 470pF 100µF C859 ECKC2H471J CERAMIC 500V C1510 ECA1HM101GB ELECT 220µF 100nF C861 ECOS2EA221AB ELECT 250V...
Seite 33
Cct Ref Parts Number Description Cct Ref Parts Number Description 100nF 100nF C1578 ECUV1H104ZFX S.M. CAP C1650 ECUV1H104ZFX S.M. CAP 100nF 100nF C1579 ECUV1H104ZFX S.M. CAP C1651 ECUV1H104ZFX S.M. CAP 100nF 100µF C1580 ECUV1H104ZFX S.M. CAP C1652 ECA1HM101GB ELECT 100nF 100nF C1581 ECUV1H104ZFX...
Seite 34
Cct Ref Parts Number Description Cct Ref Parts Number Description 100nF 47µF C1825 ECUV1C104KBX S.M. CAP C2301 ECA1CM470GB ELECT 100nF 47µF C1826 ECUV1C104KBX S.M. CAP C2302 ECA1CM470GB ELECT 100nF 10nF C1827 ECUV1C104KBX S.M. CAP C2307 ECUV1H103KBX S.M. CAP 15pF 10nF C1828 ECUV1H150JCX S.M.
Seite 35
Cct Ref Parts Number Description Cct Ref Parts Number Description 0R1µF 10nF C2449 EEANA1E1R0B CERAMIC C2637 ECUV1H103ZFX S.M. CAP 15pF 470nF C2450 ECUV1H150JCX S.M. CAP C2638 ECQM1H474J FILM 15pF C2451 ECUV1H150JCX S.M. CAP C2639 ECUV1H102KBX S.M. CAP 10nF 100pF C2452 ECUV1H103ZFX S.M.
Seite 36
Cct Ref Parts Number Description Cct Ref Parts Number Description 10nF 10nF C3120 ECUV1H103KBX S.M. CAP C3810 ECUV1H103KBX S.M. CAP 1µF C3122 ECUV1H102KBX S.M. CAP C3814 ECA1HM010GB ELECT 10nF 470µF C3123 ECUV1H103KBX S.M. CAP C3816 ECA1CM471GB ELECT 220µF C3124 ECUV1H102KBX S.M.
SCHEMATIC DIAGRAMS FOR MODEL ZEICHENERKLÄRUNG FÜR MODELL TX-W32D5DPF TX-W32D5DPF (EURO - 5 CHASSIS) (EURO - 5 CHASSIS) WICHTIGER SICHERHEITSHINWEIS IMPORTANT SAFETY NOTICE Components identified by mark have special Teile, die mit einen Hinweis gekennzeichnet sind, characteristics important for safety. When replacing any of sind wichtig für die Sicherheit, Sollte ein Auswechsein...