The valve is available in the following sizes: DN200, DN250 and DN300.
• standard
- not available
Connection type:
With drilled flanges, PN16, ISO 7005-2, EN 1092-2, EPDM lip seal
ring
Note:
... = space holder for connection size
Note:
Ordering number example for DN200: RV283P-200A
6
Assembly
6.1 Installation Guidelines
•
Install in horizontal pipework with test and drain plug
downwards
–
This position is best for draining
•
Install shut-off valves
–
Shut-off valves provide optimal serviceability
•
Ensure good access
–
Simplifies maintenance and inspection
•
Install right after water meter if applicable
–
Protects against backflow from water systems
6.2 Assembly instructions
1.
Thoroughly flush pipework
2.
Close shut-off valve on inlet
3.
Release pressure on outlet side (e.g. through water tap)
4.
Close shut-off valve on outlet
5.
Fit check valve for example between water meter and
pressure reducing valve, filter or filter combination
–
Note flow direction
–
Install without tension or bending stresses
6.
Slowly open shut-off valves on inlet and outlet
7
Maintenance
CAUTION!
In accordance with DIN EN 806-5, the following
operations should be carried out regularly. A
planned maintenance scheme is recommended.
7.1 Inspection
7.1.1Check valve
CAUTION!
Interval: once a year
1.
Close shut-off valve on outlet
2.
Open test valve
•
Until the pressure is released, some water will
flow out of the test valve. After a short period of
time the water flow should stop. If the water
continues to drip or run, then the check valve
must be replaced - see servicing of check valve
3.
Close test valve again
4.
Slowly open shut-off valve on inlet
Honeywell GmbH
GB
7.2 Maintenance
7.2.1Check valve
To be carried out by an installation company
1.
Close shut-off valve on inlet
2.
Release pressure on outlet side (e.g. through water tap)
3.
Close shut-off valve on outlet
4.
Replace check valve
5.
Slowly open shut-off valves on inlet and outlet
8
Disposal
See Chapter 4 Scope of Delivery
Observe the local requirements regarding correct
waste recycling/disposal!
6
RV283P-...A
•
MU0H-1265 GE23 R0818